Horizon Fitness MATRIX ICR50 Manual page 4

ASSEMBLY
UNPACKING
Unpack the equipment where you will be using it. Place the carton
on a level flat surface. It is recommended that you place a protective
covering on your floor. Never open box when it is on its side.
IMPORTANT NOTES
During each assembly step, ensure that ALL nuts
and bolts are in place and partially threaded.
Several parts have been pre-lubricated to aid in assembly
and usage. Please do not wipe this off. If you have difficulty,
a light application of lithium grease is recommended.
WARNING!
There are several areas during the assembly process that
special attention must be paid. It is very important to follow
the assembly instructions correctly and to make sure all parts
are firmly tightened. If the assembly instructions are not
followed correctly, the equipment could have parts that are not
tightened and will seem loose and may cause irritating noises.
To prevent damage to the equipment, the assembly instructions
must be reviewed and corrective actions should be taken.
4
TOOLS REQUIRED:
F 2.5 mm Allen Wrench
F 5 mm Allen Wrench/Screwdriver
F 6 mm Allen Wrench
F Flat Wrench (17mm)
PARTS INCLUDED:
F 1 Main Frame
F 1 Front Stabilizer Tube
F 1 Rear Stabilizer Tube
F 1 Handlebar Set
F 1 Bicycle Saddle
F 2 Pedals
F 2 Levelers
F 1 Hardware Kit
SERIAL NUMBER
MODEL: ICR50 MATRIX INDOOR CYCLE
* Use the information above when calling for service.
WARNING
1 SPINNING PEDALS CAN CAUSE INJURY.
THIS EXERCISE BICYCLE DOES NOT
HAVE A FREEWHEEL, SO PEDAL
MOTION IS DIRECTLY TIED TO MOTION
OF FLYWHEEL. USE BRAKE TO STOP
MOTION OF PEDALS AND FLYWHEEL.
2 APPLY MAXIMUM BRAKE RESISTANCE
TO BIKE WHEN NOT IN USE TO
PREVENT INJURIES CAUSED BY
MOVING CRANK ASSEMBLY AND
FLYWHEEL.
3 KEEP CHILDREN UNDER THE AGE OF
14 AWAY FROM EXERCISE EQUIPMENT.
4
ALL WARNINGS AND INSTRUCTIONS
SHOULD BE READ AND PROPER
INSTRUCTION OBTAINED PRIOR TO
USE. USE THIS EQUIPMENT FOR ITS
INTENDED PURPOSE ONLY. CONSULT A
PHYSICIAN BEFORE USING THIS
EQUIPMENT.
5 SET UP AND OPERATE THE STATIONARY
EXERCISE BICYCLE ON A SOLID LEVEL
SURFACE. CARE SHOULD BE TAKEN IN
MOUNTING AND DISMOUNTING THE
STATIONARY EXERCISE BICYCLE.
BEFORE DISMOUNTING, BRING THE
PEDALS TO A COMPLETE STOP.
6 WARNING — LOCK THE EQUIPMENT
WHEN NOT IN USE BY SETTING BRAKE
TO MAXIMUM RESISTANCE.
7 MAX USER WEIGHT - 136 KG/300 LBS.