Preparing The Electric Vehicle For Extended Off-Season Storage; Returning The Stored Electric Vehicle To Service - Club Car Electric Precedent 2008 Maintenance And Service Manual

GENERAL INFORMATION
CAUTION
• Batteries in low state of charge will freeze at low temperatures.
• To avoid exposing electrical components to moisture and subsequent damages, do not use any type
of pressure washing or steam cleaning equipment to wash the vehicle.
• Place Tow/Run switch in the TOW position.

PREPARING THE ELECTRIC VEHICLE FOR EXTENDED OFF-SEASON STORAGE

1. Fully charge batteries. See Section 16 — Batteries .
2. Batteries should be clean and free of corrosion. Wash tops and terminals of batteries with a solution of baking
soda and water (1 cup (237 mL) baking soda per 1 gallon (3.8 L) of water). Rinse solution off batteries. Do not
allow this solution to enter the batteries. Be sure terminals are tight. Let the terminals dry and then coat them with
Battery Terminal Protector Spray (CCI P/N 1014305).
3. Store vehicle in a cool, dry place. This will minimize battery self-discharge.
4. Adjust tires to recommended tire pressure. See Section 2 — Vehicle Specifications .
5. Perform all semiannual periodic lubrication. See Periodic Lubrication Schedule on page 10-5.
6. Thoroughly clean front body, rear body, seats, battery compartment, and underside of vehicle.
7. Do not engage the park brake. Chock the wheels to prevent the vehicle from rolling.
8. Keep batteries fully charged during storage.
– Leave chargers plugged in during storage. The onboard computer will automatically activate the charger when
necessary. If the battery charger is left plugged in during extended storage, the electrolyte should be checked
monthly to ensure that proper level is maintained. AC power should also be checked periodically.
– If charger cannot remain plugged in, or AC power will not be available during extended storage, disconnect
the batteries for storage. See WARNING "To avoid unintentionally starting..." in General Warnings
on page 1-1.
CAUTION
• Be sure to check the batteries and charger monthly to maintain correct battery water level and ensure
the charger is operating correctly during storage.

RETURNING THE STORED ELECTRIC VEHICLE TO SERVICE

1. If necessary, connect batteries.
2. Fully charge batteries.
WARNING
• Do not attempt to charge frozen batteries or batteries with bulged cases. Discard the battery. Frozen
batteries can explode.
3. Adjust tire to recommended pressure. See Section 2 — Vehicle Specifications .
4. Perform the Pre-Operation and Daily Safety Checklist. See Owner's Manual.
2008 Electric Precedent Maintenance and Service Manual
3
Storage
Page 3-3