lamber LINEAR 30 Instruction Manual page 24

LINEAR
Second Section - FOR THE INSTALLER
The following instructions are addressed to qualified personnel who is the only one
authorized to carry out the inspections and the necessary repairs.
The machine should be installed into a "Normal" environment, that is to say indoors, free
of dust, explosion-proof and adequately lit and well aired.
Before installing the machine, it is necessary to arrange the electrical and water
connections.
See the reported wiring diagram (supplied by the manufacturer) of the selected model as
far as the dimensions of pipes, cables and wall-mounted switch are concerned.
In order to prevent damages caused by the escape of vapours from the equipment make
sure that adjacent materials do not deteriorate in their presence.
The Manufacturer cannot assume any responsibility for any damage to persons or
property deriving from the non-observance of the above-specified norms.
DETERGENTS
The machine should also be equipped with a detergent and brightener dispenser, which
shall be supplied by the manufacturer of these products.
N.B.: If you use chlorinated sanitizers, it is always advisable to employ an automatic
dispenser provided with feeler for the measurement of the detergent concentration,
because brownish spots can appear on the surfaces due to chlorine reactions when
pouring the detergent directly into the tank. The feeler for the measurement of
concentration must be placed on the front side of the tank through the hole "A" preset for
such operation (see drawing on page 27).
In any case the LIQUID DETERGENT shall be introduced through the preset hole "B" on
the right side of the washing tank.
The choice of the right detergent is a necessary condition in order to obtain the best
washing results as regards the hygienic al aspect.
It is therefore necessary to consider some requirements.
First of all, it is necessary to use only highly Alkaline Anti-foam Products and specifical
Chloro-actives for industrial Dishwashers, made by companies of acknowledged
reliability. Just as an indication we mention some of them: Ecolab-Soilax; Henkel; Lever;
Diversey; Relativ.
The average concentration of liquid detergents must be 2-4g/lter. In any case it is
essential that the producer of the detergent rules the dosage properly according to the
features of the installation.