Clutch; Checking/Correcting The Fluid Level Of The Hydraulic Clutch; Changing The Hydraulic Clutch Fluid - Husqvarna FE 250 EU 2014 Repair Manual

19

CLUTCH

Checkin /correctin
Warning
Brake fluid causes skin irritation.
Skin irritation
-
Keep brake fluid out of the reach of children.
-
Wear suitable protective clothing and safety glasses.
-
Do not allow brake fluid to come into contact with the skin, the eyes or clothing.
-
Consult a doctor immediately if brake fluid has been swallowed.
-
Rinse the affected area with plenty of water in the event of contact with the skin.
-
Rinse eyes thoroughly with water immediately and consult a doctor if brake fluid comes into contact with the eyes.
-
If brake fluid spills on to your clothing, change the clothing.
Warning
Environmental hazard
-
Dispose of oils, grease, filters, fuel, cleaning agents, brake fluid, etc., correctly and in compliance with the applicable
regulations.
Info
The fluid level rises with increasing wear of the clutch facing discs.
Never use DOT 5 brake fluid. It is silicone-based and purple in color. Oil seals and clutch lines are not designed for DOT 5
brake fluid.
Avoid contact between brake fluid and painted parts. Brake fluid attacks paint.
Only use clean brake fluid from a sealed container.
19.2
Chan
Warning
Environmental hazard
-
Dispose of oils, grease, filters, fuel, cleaning agents, brake fluid, etc., correctly and in compliance with the applicable
regulations.
the fluid level of the h draulic clutch
Hazardous substances cause environmental damage.
-
Move the clutch fluid reservoir mounted on the handlebar to a horizontal position.
-
Remove screws
-
Remove cover
-
Check the fluid level.
I
Fluid level below container rim
If the fluid level does not meet specifications:
-
Correct the fluid level of the hydraulic clutch.
I Brake fluid DOT 4
-
Position the cover with the membrane. Mount and tighten the screws.
Info
•
I
Clean up overflowed or spilled brake fluid immediately with water.
Hazardous substances cause environmental damage.
-
Move the clutch fluid reservoir mounted on the handlebar to a horizontal position.
-
Remove screws
-
Remove cover
O.
8 8.
with membrane
14
(!!,!I p. 262)
O.
8 8.
with membrane
mm (0.16 in)
192