Page 2
THANKS General Instructions We at Kasco Marine, Inc. would like to both thank and congratulate you on your purchase of the xStream fountain. INSPECT THE SHIPMENT We appreciate you choosing Kasco and for your purchase. Immediately inspect your Kasco Fountain shipment for any Your decision to purchase Kasco’s xStream Fountain will...
Kasco Fountains are lightweight, energy eficient, and easy to install and operate. We strive to produce products that exceed customer expectations. We hope you enjoy your Kasco Fountain.
Assembly 1. Make sure you have all the parts needed. If any shortages are found, contact your Kasco representative immediately. 2. Place loat on motor housing. The power cord notch on the loat should line up with the cord. See diagram below of bottom side of loat.
7. Make sure the cord is coming out of the notch in the loat before attaching the screen to the loat. All other nozzle options require the following assembly: 1. Place the low straightener in the fountain tube making sure it rests securely against the tube and the holes line up.
oring Important: Push in black plugs on the inside of the nozzle only. Plugs on Inside 3. Prepare the nozzle before installing using the nozzle choice chart. Different patterns are created by plugging or removing plugs from the inside holes in the nozzle.
Page 12
NOTE: Pattern sizes listed are approximate. by sinking them further below the surface. Variations in voltage caused by regional electrical differences or voltage drop due to long power cords may result in reduced pattern sizes. 4. After the nozzle is prepared, attach it to the low straightener in 4 places using #6 x 1/2”...
Page 13
NEW KASCO AERATOR! C-25 Control Box will turn the aerator/fountain ON & OFF with the TIMER. Kasco lights will turn ON with the 4. Test the GFCI with the test button now and every 30 PHOTO EYE and OFF with TIMER. C-25 Control Box is days.
Page 14
** the sun and cool, but above 32 F. It is not necessary to store Kasco motors upside down. All internal seals ** Please keep the original box for maintenance ship- are fully lubricated while stored in an upright position.
Page 15
(except for www.kascomarine.com the ropes, power cord, and propeller) under normal Kasco Marine will have a record of the purchase and use and service. The Kasco Marine, Inc. obligation will be able to determine whether or not the unit still under this warranty is limited to replacing or repairing caries warranty coverage.
Page 16
Kasco Marine does estimates on repairs at the request This symptom is also caused from unit being of the customer. The request for estimate should be clogged with debris.
Page 17
This indicated a problem with the Starting Capacitor. Each Kasco Fountain is equipped with a Starting Capacitor to get the unit going when it is irst plugged in. If it is operating, but not spinning and can...
Page 18
Replacement Parts 2400SF REPLACEMENT PARTS ITEM PART TORQUE DESCRIPTION QTY. NUMBER VALUES 140112 PUMP HOUSING, LOWER PROP, 1/2HP, HIGH SPEED 361110 HAND TIGHT FOUNTAIN DISC, 1/2HP, HIGH SPEED 361115 FOUNTAIN 361500 FLOAT, 1/2 HP 251300 FLAT WASHER, 1/4" 840537 LOCK WASHER, 1/4" 1/4-20 X 3-1/4 PHIL PAN 251200 HEAD...
Page 19
Customer Repair Form 800 Deere Rd Prescott, WI 54021 Phone: 715‐262‐4488 Fax: 715‐262‐4487 www.Kascomarine.com Sales@kascomarine.com Repair Contact Form Kasco requires all Repairs sent in MUST be accompanied by this form and marked to Repairs attention. (ex. Attn: Repairs) Repairs returned should include upper pump housing or wire basket for Aerators and De‐Icers. These parts protect the motor during shipping. Kasco is NOT responsible for shipping damage accrued in return shipment. It is the responsibility of customer to ship and pay freight to Kasco. Do not ship float or control panel with unit, unless otherwise instructed A fee of $60 per hour will be assessed for cleaning excessively dirty units and float disassembly Refer to the Owner’s manual for easy‐to‐follow troubleshooting rule out site issue. Note: Contact Information Should be that of the person or company to contact for repair. Company First Name Last Name Address City State ...
Page 20
Also ill in the information below and keep for your records. Model # (Ex. 2400SF)_______________________________ Serial # (Ex. 2101S241025)______________________________ Purchase Date:_____________________ Purchased From:___________________________________ Registration Date: ___________________________ Kasco Marine, Inc. 800 Deere Rd. Prescott, WI 54021 Phone (715) 262-4488 * Fax (715) 262-4487 www.kascomarine.com * sales@kascomarine.com 884361...