Removal Of Crankshaft Engine In Car; Installation Of Crankshaft Engine; Removal Of Flywheel; Inspection And Installation Of Flywheel - Cadillac 54-6219 1954 Shop Manual

ENGINE MECHANICAL
Fig. 10-32 Tiniog Gear Lncatng Werka
& Install
ccv, front
cover gasket and install
cover over locating doweis on Itiach.
7. Install 9 ep a row
S
WILd: 'told soy or to
block and tighten to LU -12 turn1 puonds torqos
& Install engine oil pan, Note 14.
9. InstaL crankshaft polIcy.
10. Install wa:cr pump! Section 13, Noto 2:.
36
Removal of Crankshaft
Engine in Car
1
Raise car and insrall
stands onder cat at
all !our wheels
2. Remove
3. Remove
4.
&etltove
5. Remove
Die
510 Si
dc
floor.
ng chain and sprockets Note 29.
flvwhee. Note .38
oIl Dan baffle and oil pomp. Note f7.
steering geat idler arm from right
bar Lttd lower eLecting linkago Lo
7. Disconnect coisnecLing roiRs and pLish piston
assemblies op into cylinder hares go that crank
-
shaft can las removed withoot intetfering with
tods.
S. Remove frnnt and rear main hoarit.g caps.
9. SupporL cratrks haD:
at front and roar and
temov e three intermediate hear i:: caps.
lb. Lo.t at crat.kvhaf: ftoo: eng!oe.
37
Installation of Crankshaft
Engine in Cad
1. Raise ctankahaft into position and auprort
in place whie installing main hearing caps rSee
Note 21, Step 5, ositip a itc:w rcarmsin beardir cdl
.seal ass. xn lamed
in
Note 28.
2 Lubricayc!
crank
pins and pull COtifleCti!tg ted
and irsTor. a.eset h:icsitown roward crank.shaft.
Instal: nnnnecong md cops :yn ctankshaiL as
dcscrilyrd :11 Note 20.
4. Install can:shaf: sprocket, taming chain, and
t:nlisg case cover, No:e 35.
5. Install craokshslt poilev.
6. Install walor pomp osiog nc gaskcii,Scctioli
11.NuLe St.
7. Connecr steering
gear iciler an1
o
right
rrt: itto. sic! bar.
8. Install oil pomp Ness iSo.
9, install flwheel, N 39.
38
Removal of Flywheel
Raise nat 8 inches from floor and place atands
onder car at al. foor whee
2
Remove transmission as descrihod in Nero 10
3. Remove flyevheel to crankshaft halts
4. Remove fI vwhee and gaskeL from ctanPsh.aft,
39
Inspection and Installation of
Flywheel
a, Inspection
I. Inspect ail starter reedy on nheel
sodclean
up al. burred teeth, osing a fLoe fyle.
I 1:5-29
6. Remove epork pILIga