Tyres - PRONAR T700 Operator's Manual

SECTION 2
should be attached using the specifically prepared holder (2), riveted to the rear
wall of the load box.
• Do NOT exceed the trailer's maximum carrying capacity. Exceeding the carrying
capacity may lead to damage to the machine, loss of stability while driving,
scattering of the load and danger while driving. The brake system is adjusted to
the gross weight of the trailer, exceeding the weight limit causes drastic reduction
of basic braking effectiveness.
• Load must be uniformly distributed and it must not obstruct visibility or hinder
driving. The load must be secured so that it cannot move or fall over.
• During reversing one should use the assistance of another person. During
manoeuvring the person helping must stay at a safe distance from the danger
zone and be visible all the time to the tractor driver.
• Do NOT attempt to board trailer while travelling.
• Do NOT park trailer on slope.

2.1.7 TYRES

• When working with tyres, the trailer should be immobilised with parking brake and
secured against rolling by placing chocks under wheel. Wheels can be taken off
the trailer axle only when the trailer is not loaded.
• Repair work on the wheels or tyres should be carried out by persons trained and
entitled to do so. This work should be carried out using appropriate tools.
• Inspection of nut tightening should be carried out after first use of trailer, after first
travel with loading and then after 6 months use. In the event of intensive work
check the nut tightening at least every 100 km. The inspection should be repeated
individually if a wheel has been removed from the wheel axle.
• Avoid potholes, sudden manoeuvres or high speeds when turning.
• Check the tyre pressure regularly. Pressure and tyres should be also checked
after the whole day of intensive work. Please note that higher temperatures could
raise tyre pressure by as much as 1 bar. At high temperatures and pressure,
reduce load or speed. Do not release air from warm tyres to adjust the pressure
or the tyres will be underinflated when temperatures return to normal.
2.9
Pronar T700