Club Car V-GLIDE Maintenance Service Supplement page 11

PERIODIC MAINTENANCE
Maintenance and Service Manual and this supplement.
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive
maintenance procedures should be performed more often than recommended in the periodic ser-
vice and lubrication schedules.
Both the Periodic Service Schedule and the Periodic Lubrication Schedule must be followed to
keep the vehicle in optimum operating condition.
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL
Daily service by owner
Weekly service by owner
Monthly service by owner
or trained technician
Semiannual service by trained
technician only (every 50 hours of
operation or 100 rounds of golf)
Annual service by trained
technician only (every 100 hours
of operation or 200 rounds of golf)
∆
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle
until repairs are made. Failure to make necessary repairs could result in fire, property
SERVICE
Batteries
Batteries
Batteries
Tires
Wiper switch
General vehicle
Brake system
Electrical wiring and connections
Forward/Reverse switch
Front wheel alignment and camber
Batteries
2004 V-Glide 36-Volt Electric Vehicle Maintenance and Service Supplement
Periodic Service Schedule
Charge batteries after each use.
Check electrolyte level. Add water if
necessary. See Section 13 – Batteries.
Wash battery tops and clean terminals
with baking soda/water solution.
Check air pressure and adjust if
necessary. See Section 2 –
Specifications in the DS Maintenance
and Service Manual.
Check for cracks or other damage; make
sure switch is securely fastened to frame.
Check movable contact for correct
operation.
Wash battery compartment and underside
of vehicle.
Check brake shoes; replace if necessary.
See Section 6 – Wheel Brake
Assemblies in the DS Maintenance and
Service Manual.
Lubricate brake slide. See Periodic
Lubrication Schedule on page 10-4.
See also Section 6 – Wheel Brake
Assemblies in the DS Maintenance and
Service Manual.
Check brake cables for damage; replace if
necessary.
Check for tightness and damage.
Check condition of contacts and wire
connections; make sure connections are
tight.
Check and adjust as required. See
Section 7 – Steering and Front
Suspension in the DS Maintenance and
Service Manual.
If batteries are not performing as
expected, see Section 13 – Batteries.
10
Page 10-3