Toro Reelmaster 5500-D Service Manual page 282

P1
A3 B3 C3 D3 E3 F3 G3 H3 J3 K3
A2 B2 C2 D2 E2 F2 G2 H2 J2 K2
A1 B1 C1 D1 E1 F1 G1 H1 J1 K1
30 Pin Connector
Located under the control console
Plugged into the ACE control module
Cavity Wire Cavity Wire
A1 Yellow F1 Black/Red
A2 Open F2 White
A3 Violet/Red F3 Blue
B1 Yellow/Black G1 Red/Blue
B2 Green G2 Orange
B3 Orange/Brown G3 Pink
C1 Orange/Blue H1 Pink/White
C2 Green/White H2 Open
C3 Tan H3 Open
D1 Pink/Blue J1 Pink/Black
D2 Violet J2 Gray
D3 Open J3 Red/White
E1 Orange/Red K1 Red/Black
E2 Black/White K2 Black
E3 Brown K3 Black/White
P11 P12 P13
Joystick Lower
Warning light Optional Light Fuel Gauge
cluster Relay
Located under
Located under Located under Located under
the control the control the control
console console console
Cavity
Cavity Wire Cavity Wire Cavity Wire
1
1 Green/Blue 1 Red 1 Orange
2
2 Green/Black 2 Orange 2 Black
3 Ye llow 3 Open 3 Blue/Green 3
4 Black 4 Red
5 Orange/ Red 5 Black
6 Green/White
P2
A3 B3 C3 D3 E3 F3
A2 B2 C2 D2 E2 F2
A1 B1 C1 D1 E1 F1
18 Pin Connector
Located under the control console
Plugged into the ACE control module
Cavity Wire
A1 Blue/White
A2 Black
A3 Open
B1 Green/Black
B2 Open
B3 Violet/Red
C1 Red/White
C2 Open
C3 Open
D1 Yellow/White
D2 Brown/Red
D3 Black
E1 Brown/White
E2 Open
E3 Green/Pink
F1 Open
F2 Open
F3 Orange/Blue
P14 P15 P16 P17
2 1
1 2 3 1 2 3
Joystick Raise
Glow Plug Relay
MVS2 Sonenoid
Located under
Located under Located on
the control the control the operat ors
reel manifold
console console.
seat
Wire
Cavity Wire Cavity
Black Cavity Wire
1 Red/White A Brown/White
Pink 1 Black
Orange/Red B
Open 2 Violet
2 Black
3 Open
P3 P4
Communications Loop−B ack
Port connector
Located in the Located in the
control console control console
Cavity Wire Wire Color
A Yellow Gray
B Green/Pink
C Black
D Open
E Orange/Blue
F Open
P6 P9
4 5
1
3 2
Diagnostic Light
Ignition Switch
Located in the Located in the
control console control console
or steering tower
Wire Color
Brown/red
Cavity Wire
Ye llow
1 Open
2 Open
3 Orange
4 Red/Blue
5 Violet/Red
P18 P19 P20
Rear Reel MSV1 Solenoid Lift Arm Sensor
Backlap Switch
Located on Located on Located on left
reel manifold hand front lift
reel manifold
arm
Wire Cavity Wire Cavity Wire Cavity Wire
A White A Ye llow/White A Black/White
Black B Black B Black B Black
P5
P7
10 AMP
1 2
20 AMP
Leak Detector 3 4
5 6 10 AMP
Located in the
control console
7 8
10 AMP
Cavity Wire
A Orange
B Black
C Red/White
Fuse Holder B
D Brown/Red
Located in the
control console
P10
Cavity Wire
1 Red
2 Blue/White
Green/Black
3 Open
4 Red/Blue
5 Open
6 Pink/Black
Te mp Gauge
7 Red
8 Red/Black
Located in the
control console
Cavity Wire
1 Orange
2 Black
3 Blue/White
P21 P22 P23
1 2
Parking Brake Starter Alternator
Switch
Located in Located on "S" Located on the Located on
terminal of the LH front of the Starter ground
steering tower
starter
engine
Wire Color
Cavity Wire Cavity Wire
Orange
A Orange/Brown 1 Pink/Blue Fusible Link
B Black 2 Green/Black
Reelmaster 5500-D
Electrical Connector Drawing
(Serial Number Below 210000200)
P8
4 AMP
1 2
7.5 AMP
3 4
5 6
7 8
Fuse Holder A
Located in the
control console
Cavity Wire
1 Yellow
2 Yellow
3 Orange
4 Orange
5 Open
6 Red
7 Red
8 Open
P24 P25
Starter Battery Cable
Located on the
RH side of the
terminal engine, By the
starter
Wire Color Cavity Wire
A Red
B Red
C Red
Page 10 - 6
Rev. C