Volkswagen Golf 2015 Repair Manual page 29

– Place the gauge button
-on the hub of the large clutch pack carrier-.
• The tip of the dial may not be placed on the circlip.
– Adjust the -dial gauge- pretension again to »0«.
– Raise the clutch up as far as the stop again and note this
measurement as well
Now the Calculation Will Be Made to Determine Which of the Re‐
maining Nine Circlips Will Be Finally Installed:
The new circlip will be determined according to the following for‐
mula:
2nd Measured value – 1st Measured value + 1.85 mm = thick‐
ness of circlip to be installed
– Write down the result.
The remaining nine circlips are staggered in 0.1 mm increments.
– Measure all the circlips and determine the one that is the
closes match to the result
Determined Measurement for
the New Circlip
2.27 mm
2.24 mm
– Remove the 2 mm circlip and replace it with the circlip that was
measured.
– Dispose of all other rings remaining and the 2 millimeter thick
ring.
Note
Circlips must only be installed one time.
– Insert the pump shaft.
Note
The pump shaft must be slightly lifted and rotated in direction of
-arrow- in order for it to completely slide into the splines.
Golf 2015 ➤ , Golf Variant 2015 ➤
Direct Shift Gearbox - Edition 09.2015
New Circlip
2.3 mm
2.2 mm
25
1. Clutch