EGO Power+ ZT4200L Operator's Manual page 60

PROBLEM
The mower is not tracking
straight.
The parking brake pedal
cannot not be released from
the braking position or is
slow to spring back.
The mower cannot be
charged via charging port
with the mower status indi-
cator shinning solid red.
The charging time via the
mower charging port is too
long.
The battery cannot be
fully charged via the mower
charging port.
The mower cannot be
started after cleaning.
It is easy for the mower to be
clogged.
The mower easily loses trac-
tion when climbing up on the
slope.
When the mower is stopped
on a slope with the parking
brake pedal pressed, the
mower can slide downward
the slope.
60
56-VOLT LITHIUM-ION ELECTRIC ZERO TURN MOWER — ZT4200L/ZT4200L-FC
CAUSE
◾
The tire pressures for the left and right rear
wheels are different.
◾
The driving speed for the left and right rear wheels
are different.
◾
There may be debris or dirt getting inside the
parking braking pedal.
◾
The plug of the charger is not correctly inserted
into the charging port on the mower.
◾
There is no power in the wall outlets.
◾
Charger malfunction.
◾
The charger port on the mower is defective.
◾
The charger is not suitable.
◾
The battery or the charger failure.
◾
Improper cleaning, such as water getting on the
electric components, LCD screen etc.
◾
The mower deck is clogged with grass and debris.
◾
The tires of the rear wheels are worn.
◾
The brake components are excessively worn due
to improper operation of the mower.
SOLUTION
◾
Check and adjust the air pressure in both rear wheel
tires, according to the recommendation in section
"CHECKING THE TIRE PRESSURE" in this manual.
◾
Calibrate the mower tracking system following the
instructions in section "CALIBRATE THE MOWER
TRACKING SYSTEM".
◾
Open the parking brake pedal box to thoroughly clean
the box inside and close it. Resetting the parking
pedal to see whether the problem is solved. If not,
contact a qualified service technician for repair.
◾
Reconnect the charger plug to see whether the
mower can be charged normally.
◾
No action is needed. Wait until the power recovers.
◾
Contact a qualified service technician for inspection
and have charger repaired if needed.
◾
Contact a qualified service technician for repair.
◾
Use EGO charger CHV1600/CHV1600-FC for charging
the electric zero turn mower directly.
◾
The mower status indicator will shine solid red in
case of the charger failure, while it is off in case of
the battery pack failure. Have the charger and/or the
battery pack serviced or replaced.
◾
Follow the instructions in section "GENERAL
MAINTENANCE" and "CLEANING THE MACHINE" to
clean the mower correctly.
◾
If the mower caught in rain accidentally, leave it for
over 12 hours to dry or use compressed air to dry it.
◾
Clean the mower deck after each use, following the
section "Using Wash Port to Clean Mower Deck".
◾
Seek local service to replace the wheel tires or when
the wheel itself is damaged replace the rear wheel
following the instructions in section "REPLACING THE
WHEELS".
◾
Contact a qualified service technician for repair.