Product Information - Rcom MARU DELUXE Hatcher & Brooder MX-100HBD User Manual

6. Product Information

Replace the Fuse
Back
▶ Fuse is located at the top of
power connection part on
back side of machine.
General maintenance
All our Rcom digital products of Autoelex Co., Ltd. are made by precision systems under strict quality control. But
occasionally some defective products are found on the way of their distribution.If any problem occurs, then please
contact Autoelex service center or distributorsin your country. We will do our best to solve the problems, if any,
for you. This product is designed in modular mode, so for its repair, if any, a qualified person can replace the part
concerned with ease.
* Complaint Department : 82-55-337-2560
Troubles
In case hatching rate
is low
When a chick hatches
out earlier than expected
or a deformed chick
hatches out
When a chick hatches
out later than
expected
When hatching dates are
so different from each egg
(When all chicks don't
hatch out at the same time
but over a long period)
18
(1) How to Service your MARU H&B
Replacing the Fuse,
General maintenance
▶ When the fuse is damaged,
remove the fuse at the inside
below of power connection
part, with screwdriver.
Expected Causes (Possibility)
▶ When the egg is an unfertilized egg.
▶ Getting infected by germs.
▶ Wrong incubation setting.
▶ Health condition of mother bird.
▶ Improper egg turning.
▶ Setting temperature high.
▶ Setting temperature low.
▶ Eggs stored for different lengths of time.
▶ Diffferent incubation temperatures.
▶ Replace ⓐ(Used Fuse) fuse
with ⓑ(Spare Fuse) fuse.
For AC 100V use :
250V 8.0A Ø5*20mm
For AC 230V use :
250V 8.0A Ø5*20mm
＊E-mail Receipt : Rcom@Rcom.co.kr
Countermeasures
▶ Inspect the egg to check possibility
of egg surviving.
▶ Disinfect the machine.
▶ Check all settings of machine.
Especially, check them focusingon the
temperature.
▶ Review care of health of mother bird.
▶ Lower temp. setting of the
machine about 0.5℃ (1℉)
ex) 37.5℃ (99.5℉) → 37.0℃ (98.6℉)
▶ Raise temp. setting of the machine
about 0.5℃ (1℉)
ex) 37.0℃ (98.6℉) → 37.5℃ (99.5℉)
▶ Minimize the time to store egg properly.
▶ Check Temperature difference in the
machine.
(sunlight, temp of incubation room, etc.)
DIGITAL INCUBATOR