Daikin RDT-135c Installation And Maintenance Manual page 129

Warranty Registration Form (continued)
VI. GAS & OIL BURNER CHECK, TEST, & START
Specifications:
For gas, see Forced Draft Gas Burner Installation and Maintenance Bulletin .
For oil, see Oil Fired Furnace Installation and Maintenance Bulletin .
A. (Gas/Oil) Furnace model no. __________________
B. (Gas/Oil) Burner model no.___________________
C. (Gas) Type firing:
D. (Oil) Type firing start:
E. (Gas) Rated firing rate: _________________ MBH input
F. (Oil) Rated firing rate: _________________ GPH, #2 fuel oil
G. (Gas/Oil) Altitude: ___________________ ft. above sea level
H. Is there a circulating tank? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
VII. GAS BURNER CHECK, TEST, & START
A. Input:________________________________ CFH
B. Gas pressure at burner: ________________inches w.c.
C. CO : __________________________ %
2
D. CO : __________________________ %
2
E. Pilot flame only: ______________ microamps (steady at low fire)
F. Pilot Tap-gas pressure: _________________inches w.c.
G. Motor only/burner: FLA __________________ running amps
H. High limit control OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
I. Flame safeguard: ________________ microamps
J. Flame failure shutoff: _______________ seconds
K. Airswitch OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
L. High Gas Pressure Switch OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
M. Low Gas Pressure Switch OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
N. Main Gas Valve Close-off OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
VIII. OIL BURNER CHECK, TEST & START
A. Nozzle(s): Type/manufacturer
B. Nozzle pressure: _______________________ psi
C. CO : __________________________ %
2
D. Smoke spot: number_______________
E. Running amps_________________ FLA
F. Flame safeguard: microamps _________________
G. High limit control OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
H. Flame failure shutoff OK? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
I. Ignition failure check OK?. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes
.
IX Have all electronic or electrical controls been checked, adjusted, and tested for proper operation per the
installation and maintenance bulletins?
X. MAINTAINING MICROTECH CONTROL PARAMETER RECORDS
After the unit is checked, tested, and started and the final control parameters are set, record the final settings. Keep these records on file and
update whenever changes to the control parameters are made. Keeping a record facilitates any required analysis and troubleshooting of the
system operation and facilitates restoration after a controller replacement.
Signature: ______________________________________________________
RETURN COMPLETED FORM TO:
Daikin Applied Warranty Department, 13600 Industrial Park Boulevard, Minneapolis, MN 55441
Please list any additional comments that could affect the operation of this unit; e.g., shipping damage, failed components, adverse installation
applications, etc., on a separate sheet and attach to this form.
IM 738-2
Serial no. ___________________
Single Stage two
Full fire start Low fire start
GPH
Rooftop Equipment Warranty Registration Form
Stage modulation
Angle Pattern manufacturer
Startup date: ___________________________________
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
No N/A
Yes No N/A
127