Carefree TRAVEL'RFIXED PITCH Service Manual page 48

Carefree of Colorado
A C
WNING ARE
Maintaining a Carefree Awning is easy. Just follow these basic steps:

Always operate the awning according to the instructions.

Periodically check that the fasteners are tight. Tighten if necessary.

Keep the awning fabric and arms clean.
F C
ABRIC ARE
NOTICE
DO not use oil based cleaners or any caustic, granulated, or
abrasive type cleaners on your Carefree product.
1. One of the best ways to keep the fabric looking good and to delay the need for
deep or vigorous cleanings is to hose fabrics off on a monthly basis with clear
water. This practice helps prevent dirt from becoming deeply imbedded in the
fabric. In most environments, a thorough cleaning will be needed every two to
three years.
2. When it's time for a thorough cleaning, the fabric can be cleaned while still
on the awning frame.

For Vinyl Fabric – Use a soft brush and warm water with soap.

For Acrylic Fabric – Use a stiff brush and warm water with soap.
3. When cleaning the fabric, it is important to observe the following:

Always use a natural soap, never detergent.

Water should be cold to lukewarm, never more than 100F.

Air-dry only. Never apply heat to the fabric.

Always allow the fabric to dry thoroughly before rolling up the awning.
M
ILDEW
Mildew is a fungus growth that looks like dirt. Vinyl coated polyester fabrics are
mildew resistant because of a chemical biocide in the vinyl coating.
ordinary conditions, mildew will not appear.
temperature and humidity are common, mildew can be a problem and require the
material to be washed more frequently.
P
OOLING
When water collects on the top of the fabric, this is known as "pooling". This can
occur during inclement weather or if a running air conditioner discharges over the
awning. The water is dumped when the awning is retracted. It is recommended
that if water accumulates on the top; retract the awning in steps (8"-12") to dump the
water. This will help prevent the fabric from stretching or distorting.
The effects of wind and rain on an awning are unpredictable.
damage to the awning and the vehicle may result. I
PERIODS OF RAIN ARE EXPECTED
L
EAKING
On vinyl canopies, side hems and poly cords are stitched in with a sewing machine. On
occasion, this stitching may allow water to seep or leak through. This is normal and not
a defect covered by warranty. Treat the seams with a quality seam sealer.
A C
RM ARE
The best method of keeping the arms and braces operating smoothly is to clean them.
Dirt and debris can cause the arms not to move easily. Periodically wash out the
channels with running water (i.e. a hose). If the arms still do not move easily, lightly
spray the joints and pivot points with a dry silicone lubricant after the arms have been
cleaned and dried thoroughly.
,
ROLL UP THE AWNING AND SECURE FOR TRAVEL
However, in areas where high
F WIND OR EXTENDED
Under
Severe
.