Yamaha SRX700D Service Manual page 35

Item
Slide runner Check for wear and damage.
Replace if necessary.
Brake/parking brake Check operation and fluid leakage.
Adjust free play and/or replace pads if necessary.
Change brake fluid.
Disk brake installation Check for slight free play.
Lubricate shaft with specified grease as required.
Drive chain oil Check oil level.
Change.
Drive chain Check deflection.
Adjust if necessary.
Ski/ski runner Check for wear and damage.
Replace if necessary.
Steering system Check operation.
Adjust toe-out if necessary.
Lights Check operation. Replace bulbs if necessary.
Primary sheave Check engagement and shift speed.
Adjust if necessary.
Check for wear and damage. Replace if necessary.
Lubricate with specified grease.
Secondary sheave Lubricate with specified grease.
Adjust if necessary.
Steering column bearing Lubricate with specified grease.
Ski and front suspension Lubricate with specified grease.
Suspension component Lubricate with specified grease.
Parking brake cable end
Lubricate with specified grease.
and lever end/throttle
Check cable damage. Replace if necessary.
cable end
Shroud latches Make sure the shroud latches are hooked.
Fittings/fasteners Check tightness. Repair if necessary.
Service tools/spare parts Check for proper placement.
NOTE:
Brake fluid replacement:
1. When disassembling the master cylinder or caliper, replace the brake fluid. Regularly check the brake
fluid level and add fluid as required.
2. On the inner parts of the master cylinder and caliper, replace the oil seals every two years.
3. Replace the brake hoses every four years, or if cracked or damaged.
PERIODIC MAINTENANCE TABLE
Remarks
2-2
INSP
ADJ
Initial
Pre- 1 month
operation or
check first 800 km
(daily) (500 mi)
(40 hr)
See NOTE.
After the first 80 km (50 mi) and every 800 km
(500 mi) thereafter
Whenever operating elevation is changed
Whenever operating elevation is changed
Every
Seasonally
or
3,200 km
(2,000 mi)
(160 hr)
2
Every 1,600
km (1,000 mi)