Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Yamaha SRX700D
Summary of Contents for Yamaha SRX700D
- Page 1 SRX700D, SRX700SD...
- Page 2 NOTICE HOW TO USE THIS MANUAL MANUAL FORMAT EXPLODED DIAGRAM...
-
Page 3: Illustrated Symbols
ILLUSTRATED SYMBOLS... - Page 4 INDEX...
-
Page 8: Chapter 1. General Information
CHAPTER 1. GENERAL INFORMATION MACHINE IDENTIFICATION FRAME SERIAL NUMBER ENGINE SERIAL NUMBER... - Page 9 IMPORTANT INFORMATION PREPARATION FOR REMOVAL AND DISASSEMBLY ALL REPLACEMENT PARTS...
- Page 10 GASKETS, OIL SEALS, AND O-RINGS LOCK WASHERS/PLATES AND COTTER PINS BEARINGS AND OIL SEALS CIRCLIPS LOCTITE®...
- Page 11 SPECIAL TOOLS FOR TUNE UP...
- Page 12 FOR ENGINE SERVICE FOR POWER TRAIN SERVICE...
- Page 13 FOR CARBURETION SERVICE FOR ELECTRICAL SERVICE...
-
Page 14: Chapter 2. Periodic Inspection And Adjustment
CHAPTER 2. PERIODIC INSPECTION AND ADJUSTMENT INTRODUCTION PERIODIC MAINTENANCE TABLE... - Page 16 ENGINE SPARK PLUGS...
-
Page 17: Oil Pump
OIL PUMP... -
Page 18: Fuel Line Inspection
FUEL LINE INSPECTION... - Page 19 COOLING SYSTEM...
- Page 23 CARBURETOR SYNCHRONIZATION ENGINE IDLE SPEED ADJUSTMENT...
-
Page 24: Throttle Cable Freeplay Adjustment
THROTTLE CABLE FREEPLAY ADJUSTMENT... -
Page 25: Throttle Override System (T.o.r.s.) Check
THROTTLE OVERRIDE SYSTEM (T.O.R.S.) CHECK... - Page 26 STARTER (CHOKE) CABLE FREEPLAY ADJUSTMENT EXHAUST SYSTEM INSPECTION...
- Page 27 HEAT SHIELD CLAMP REPLACEMENT...
- Page 28 YAMAHA POWER VALVE SYSTEM (Y.P.V.S.) ADJUSTMENT...
- Page 29 YAMAHA POWER VALVE SYSTEM (Y.P.V.S.) PRE-SEASON CHECKS...
- Page 31 POWER TRAIN SHEAVE DISTANCE AND OFFSET ADJUSTMENT...
-
Page 33: Drive V-Belt
DRIVE V-BELT... - Page 35 ENGAGEMENT SPEED CHECK PARKING BRAKE PAD INSPECTION PARKING BRAKE ADJUSTMENT...
-
Page 36: Brake Lever Adjustment
BRAKE LEVER ADJUSTMENT... - Page 37 BRAKE FLUID LEVEL INSPECTION BRAKE PAD INSPECTION...
- Page 38 BRAKE HOSE INSPECTION AIR BLEEDING (HYDRAULIC BRAKE SYSTEM)
-
Page 39: Drive Chain
DRIVE CHAIN... -
Page 42: Track Tension Adjustment
TRACK TENSION ADJUSTMENT... -
Page 43: Slide Runner Inspection
SLIDE RUNNER INSPECTION... - Page 44 CHASSIS SKI/SKI RUNNER STEERING SYSTEM...
- Page 46 LUBRICATION...
- Page 47 ELECTRICAL HEADLIGHT BEAM ADJUSTMENT...
- Page 48 TUNING CARBURETOR TUNING...
- Page 55 CLUTCH...
-
Page 56: Gear Selection
GEAR SELECTION... -
Page 62: High Altitude Tuning
HIGH ALTITUDE TUNING... -
Page 63: Front Suspension
FRONT SUSPENSION... -
Page 65: Rear Suspension
REAR SUSPENSION... - Page 69 CHAPTER 3. CHASSIS STEERING...
- Page 71 INSPECTION...
-
Page 72: Installation
INSTALLATION... - Page 75 INSPECTION...
- Page 76 FRONT SUSPENSION...
- Page 77 HANDLING NOTES INSPECTION...
- Page 79 INSTALLATION...
- Page 82 CHAPTER 4. POWER TRAIN PRIMARY SHEAVE AND DRIVE V-BELT...
- Page 84 R E M O V A L DISASSEMBLY...
- Page 85 INSPECTION...
- Page 87 ASSEMBLY...
- Page 89 INSTALLATION...
-
Page 90: Secondary Sheave
SECONDARY SHEAVE... - Page 92 DISASSEMBLY INSPECTION...
- Page 93 ASSEMBLY...
- Page 95 INSTALLATION...
-
Page 96: Drive Chain Housing
DRIVE CHAIN HOUSING... - Page 97 INSPECTION...
- Page 99 INSTALLATION...
- Page 100 JACKSHAFT...
- Page 101 INSPECTION...
-
Page 102: Jackshaft And Drive Chain Housing Installation
JACKSHAFT AND DRIVE CHAIN HOUSING INSTALLATION... - Page 103 BRAKE...
-
Page 104: Brake Pad Replacement
BRAKE PAD REPLACEMENT... - Page 108 BRAKE CALIPER DISASSEMBLY BRAKE CALIPER INSPECTION AND REPAIR...
- Page 109 BRAKE CALIPER ASSEMBLY BRAKE CALIPER INSTALLATION...
- Page 111 INSPECTION BRAKE MASTER CYLINDER ASSEMBLY INSTALLATION...
-
Page 112: Slide Rail Suspension
SLIDE RAIL SUSPENSION... - Page 117 INSPECTION INSTALLATION...
-
Page 118: Front Axle And Track
FRONT AXLE AND TRACK... - Page 119 INSPECTION INSTALLATION...
-
Page 120: Exhaust Assembly
CHAPTER 5. ENGINE EXHAUST ASSEMBLY... -
Page 122: Installation
R E M O V A L INSTALLATION... -
Page 124: Engine Assembly
ENGINE ASSEMBLY... - Page 125 INSPECTION INSTALLATION...
-
Page 126: Cylinder Head And Cylinder
CYLINDER HEAD AND CYLINDER... - Page 128 R E M O V A L...
- Page 129 INSPECTION...
- Page 134 INSTALLATION...
-
Page 137: Oil Pump, Crankcase And Crankshaft
OIL PUMP, CRANKCASE AND CRANKSHAFT... - Page 138 INSPECTION...
- Page 140 INSTALLATION...
- Page 142 AC MAGNETO...
- Page 143 R E M O V A L...
- Page 144 INSTALLATION...
-
Page 146: Recoil Starter
RECOIL STARTER... - Page 147 R E M O V A L INSPECTION...
- Page 148 INSTALLATION...
- Page 149 YAMAHA POWER VALVE SYSTEM (Y.P.V.S.)
- Page 151 R E M O V A L INSPECTION ASSEMBLY...
- Page 152 INSTALLATION...
-
Page 154: Chapter 6. Cooling System
CHAPTER 6. COOLING SYSTEM HEAT EXCHANGER... - Page 155 INSPECTION INSTALLATION...
-
Page 156: Water Pump
WATER PUMP... - Page 157 R E M O V A L INSPECTION INSTALLATION...
- Page 158 OUTLET WATER JACKET JOINT...
- Page 159 INSPECTION...
- Page 160 INSTALLATION...
- Page 161 CHAPTER 7. CARBURETION CARBURETORS...
- Page 165 INSPECTION...
- Page 166 ASSEMBLY...
-
Page 168: Fuel Level Adjustment
FUEL LEVEL ADJUSTMENT... - Page 169 THROTTLE POSITION SENSOR (TPS) INSPECTION AND ADJUSTMENT...
- Page 171 INSTALLATION...
-
Page 172: Fuel Pump
FUEL PUMP... - Page 173 INSPECTION INSTALLATION...
-
Page 174: Chapter 8. Electrical
CHAPTER 8. ELECTRICAL SWITCH INSPECTION SWITCH INSPECTION INSPECTING A SWITCH SHOWN IN THE MANUAL... - Page 175 IGNITION SYSTEM CIRCUIT DIAGRAM...
-
Page 176: Troubleshooting
TROUBLESHOOTING... - Page 177 SPARK PLUG CAP IGNITION COIL AC MAGNETO...
- Page 178 SPARK PLUG THROTTLE OVERRIDE SYSTEM (T.O.R.S.)
- Page 179 HANDLEBAR SWITCH (RIGHT) CARBURETOR SWITCH...
- Page 180 MAIN SWITCH CONDENSER...
-
Page 181: Emergency Engine Starting
EMERGENCY ENGINE STARTING... - Page 182 LIGHTING SYSTEM CIRCUIT DIAGRAM...
- Page 183 TROUBLESHOOTING...
-
Page 184: Headlight Beam Switch
BULB(S) HEADLIGHT BEAM SWITCH... - Page 185 HEADLIGHT RELAY LOAD CONTROL RELAY...
- Page 186 SIGNAL SYSTEM CIRCUIT DIAGRAM...
- Page 187 TROUBLESHOOTING...
- Page 190 TAIL/BRAKE LIGHT BULB BRAKE LIGHT SWITCH...
-
Page 191: Water Temperature Sensor
WATER TEMPERATURE SENSOR... - Page 192 OIL LEVEL SWITCH FUEL SENDER...
- Page 193 GRIP WARMER SYSTEM CIRCUIT DIAGRAM...
- Page 194 TROUBLESHOOTING...
- Page 195 GRIP AND THUMB WARMER COIL VARIABLE RESISTOR...
- Page 196 YAMAHA POWER VALVE SYSTEM (Y.P.V.S.) CIRCUIT DIAGRAM...
- Page 197 TROUBLESHOOTING...
- Page 198 SERVOMOTOR...
-
Page 199: Fault Location Table
FAULT LOCATION TABLE... -
Page 201: Chapter 9. Specifications General Specifications
CHAPTER 9. SPECIFICATIONS GENERAL SPECIFICATIONS... - Page 203 MAINTENANCE SPECIFICATIONS ENGINE...
-
Page 206: Power Train
POWER TRAIN... - Page 210 CHASSIS...
- Page 211 ELECTRICAL...
-
Page 213: High Altitude Settings
HIGH ALTITUDE SETTINGS... -
Page 214: Tightening Torque
TIGHTENING TORQUE... -
Page 218: General Torque Specifications Definition Of Units
GENERAL TORQUE SPECIFICATIONS DEFINITION OF UNITS... -
Page 219: Cable Routing
CABLE ROUTING...