Page 2
WARNING The engine exhaust from this product contains chemicals known to cause cancer, birth defects or other reproductive harm.
Page 3
We’ve created a web site, just for YOU!! S Technical tips S New product introductions S Event schedules S Parts and Service Manual information S Exciting details about The Way Out Check it out... www.polarisindustries.com...
Page 5
CopyrightE 2001 Polaris Industries Inc. All rights reserved. Victory Motorcycles is a registered trademark of Polaris Industries Inc. Dunlop is a registered trademark of Dunlop Tire Corporation. Features of Victory motorcycles are covered by U.S. Patent Nos. D397976, D398065, D407169, D409551, D416831, D436561, with additional patents pending.
Page 7
Foreword Thank you for choosing a Victory Motorcycle! The Owner’s Manual contains information on the following Victory Motorcycles: V92C Standard Cruiser V92C Deluxe Cruiser All photographs and illustrations used are generalizations, and your specific model may be slightly different than what is shown.
Page 8
Your authorized Victory dealer will resolve all issues regarding the motorcycle. If you are unsatisfied with the performance of your Victory dealer, contact Polaris Customer Service at 763- -417- -8650. Victory motorcycles comply with all federal, state, and local safety and emission regulations for the area of intended sale.
Page 13
..Maintaining During Storage ... . V92C Deluxe Cruiser ....Removing from Storage .
Page 14
Table of Contents V. This Warranty Is In Addition To The Victory Limited Motorcycle Warranty..VI. Additional Information....Victory Motorcycle Warranty Policy .
The Owner’s Manual contains information that is essential to safe riding and proper maintenance of all 2002 Victory motorcycles. Anyone who uses the motorcycle (Operators and Passengers) must read the Owner’s Manual before riding. Carefully read and understand the information found in the ”Safety Precautions”...
Introduction Symbols and Terms Used in the Owner’s Manual The following signal words and symbols appear in the Owner’s Manual. Your safety, and the safety of others are involved when these words and symbols are used. Become familiar with their meanings before reading the Owner’s Manual.
Safety Precautions WARNING Improper use of this motorcycle can result in serious injury or death. To minimize the risk of injury to you, your passenger, and others, read and understand the information contained in this section before operating the motorcycle. This section contains safety information specific to the Polaris Victory, as well as information about general motorcycle safety.
Break- -in” on page 57. Operating the motorcycle without following break- -in procedures can result in serious engine damage. Some Victory motorcycles include saddlebags, a windshield, and a passenger backrest as standard equipment. Under certain conditions it may be necessary to reduce the operating speed of motorcycles...
Safety Precautions Safe Riding Practices Follow these general safe riding practices: Before you ride, make sure you can operate the motorcycle safely and properly by following the recommendations given at the beginning of the Safety Precautions section on page 3. Each time you ride, make the checks described in the Pre- -Operation Check section.
Page 20
Safety Precautions Safe Riding Practices (continued) The most common cause of accidents involving a motorcycle and an automobile is the automobile driver’s failure to see the motorcycle. Ride defensively, as if you are invisible to other motorists, even in broad daylight. Ride where you are visible to other motorists and observe their behavior carefully, as they may not see or be aware of you.
Page 21
Safety Precautions Safe Riding Practices (continued) If in doubt, reduce your speed when: - - The weather is windy, raining, or otherwise causing slippery or rapidly changing conditions. - - The traffic is heavy, congested, not allowing sufficient space between vehicles, or otherwise not flowing smoothly.
Safety Precautions Safe Riding Practices (continued) Ground clearance is reduced when you lean the motorcycle. Do not allow components to contact the road surface when leaning the motorcycle in a curve, as this could cause you to lose control of the motorcycle. Retract the sidestand fully before riding.
Safety Precautions Carrying a Passenger (continued) Adjust your riding style to compensate for the differences in handling, acceleration, and braking caused by the additional weight of the passenger. Failure to do so can cause you to lose control of the motorcycle.
Safety Precautions Protective Apparel (continued) Wear heavy boots and pants to prevent or reduce abrasions, lacerations, or burns that you can suffer if you fall. Wear boots with low heels because boots with high heels can catch on pedals or footrests. The combination of your boots and pants should completely cover your legs, ankles, and feet, protecting you from engine and exhaust system heat.
Page 25
Safety Precautions Example 1: V92C Standard Cruiser with no accessories or cargo Gross Vehicle Weight Rating 1150 lbs (522 kg) Item Weight Standard Cruiser - with full capacity of all fluids 675 lbs (306 kg) Operator - with recommended riding apparel...
Safety Precautions Loading Use the following guidelines when attaching cargo or accessories to the motorcycle. Where applicable, these guidelines refer to accessories and their contents. Keep cargo and accessory weight to a minimum, and keep it as close to the motorcycle as possible, to minimize a change in the motorcycle’s center of gravity.
Safety Precautions Saddlebags Saddlebags are included with some Victory models. Use the following guidelines when operating a motorcycle with saddlebags installed. Never ride a motorcycle with saddlebags above 80 mph (120 km/h). Depending on load and weather conditions, the maximum safe operating speed may be less than 80 mph (120 km/h). Saddlebags can make the motorcycle unstable due to the lifting or buffeting effects of wind and can cause you to lose control of the motorcycle.
Safety Precautions Parking For complete parking procedures, see “Parking” page 67. When leaving the motorcycle unattended, turn the engine off, engage the steering lock, and take the ignition key with you. The engine and exhaust system are very hot after the engine has been running. Therefore, park the motorcycle where people are not likely to touch the engine or exhaust system or place combustible materials in close proximity to these hot areas.
Safety Precautions Product Modifications Modifying the motorcycle by removing any equipment or adding equipment not approved by Victory may void your warranty. Such modifications may also make the motorcycle unsafe to ride and could severely injure you or others or damage the motorcycle. Some modifications may be illegal in some states. If in doubt, contact your authorized Victory Dealer.
Safety Precautions Selecting and Installing Accessories (continued) Do not install electrical accessories that exceed the capacity of the motorcycle’s electrical system. An electrical failure could result and cause hazardous loss of engine power or lights, or damage to the electrical system. If you want to add a windshield, backrest, or luggage rack, choose one designed and approved by Victory specifically for your model, and follow the instructions for proper installation and use.
Safety Precautions Gasoline and Exhaust Gases (continued) Gasoline and gasoline vapors are poisonous and can cause severe injury. Do not swallow gasoline, inhale gasoline vapors, or spill gasoline on yourself or your clothes. If you swallow gasoline, inhale more than a few breaths of gasoline vapor, or get gasoline in your eyes, see a physician immediately.
Page 32
Safety Precautions see the Victory Service Manual or your authorized Victory Dealer for tire replacement. Operating the motorcycle with improper tire pressure or tread condition, or improper wheel or tire balance, can make the motorcycle hard to handle and cause you to lose control of the motorcycle. Check proper steering head bearing adjustment.
Safety Precautions Location of Safety and Vehicle Information Labels (49 state models only) (California models only) For All Models (Standard Cruiser Left Side Shown)
Page 34
Safety Precautions Location of Safety and Vehicle Information Labels (continued) (Standard Cruiser label shown) (under seat) (under side cover) (on left crankcase half) Engine Identification Number Label For All Models (Standard Cruiser Right Side Shown)
Page 35
Safety Precautions Location of Safety and Vehicle Information Labels (continued)‘ (inside saddlebag) For Deluxe Cruiser (Left Side Shown)
Safety Precautions Reporting Safety Defects If you believe that your vehicle has a defect that could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Polaris Industries in writing. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
Motorcycle Description Use the following information to identify and locate the major components of the Victory motorcycle. Information on vehicle and engine identification numbers, model number, and the ignition key number is also provided. For All Models (Standard Cruiser Operator’s View Shown) 1.
Page 38
Motorcycle Description For All Models (Standard Cruiser Left Side Shown) 1. Front Forks - page 85 8. Battery (under side cover) - page 105 16.Horn - page 39 2. Front Turn Signal/Running Light - 9. Operator’s Seat - page 104 17.Passenger’s Foot Rest page 39 10.Seat Strap...
Page 39
Motorcycle Description For All Models (Standard Cruiser Right Side Shown) 1. Drive Belt (under guard) - page 77 9. Headlamp - page 39 17.Rear Brake Fluid Reservoir (under side cover) - page 96 2. Passenger’s Seat - page 104 10.Steering Lock - page 29 18.Drive Sprocket (under cover) - page 77 3.
Motorcycle Description Vehicle Identification Number The vehicle identification number (VIN) is stamped into the front of the steering head and also appears on the certification label. You will need the vehicle identification number to title, register, license, or insure the motorcycle, or to order replacement parts.
Motorcycle Description Ignition Key Number The ignition key identification number is stamped into the shaft of each key. With the ignition key number and proof of ownership, an authorized Victory dealer can assist you in obtaining a replacement key (have your dealer reference Voice of Victory April/May 2001). For easy reference, record all vehicle numbers in the space provided on page 138.
Instruments and Controls Ignition Key The ignition key operates the steering lock and the ignition switch/seat latch. Steering Lock The motorcycle is equipped with a steering lock to deter others from moving or using the motorcycle. The steering lock is on the right side of the steering head.
Run position (see page 40) you can start 2. On 4. Seat Release the engine. You can also activate the emergency flashers, turn (V92C Std/Dlx Cruiser) signals, and all other electrical features. Caution Before starting the engine, read the instructions for starting the engine on page 60.
To release the operator’s seat, insert the ignition key into the ignition switch/seat release and turn the key counterclockwise. Helmet Holders The helmet holders are a secure place to store your helmet while the motorcycle is parked. The V92C Standard and Deluxe Cruisers have two (2) helmet holders (one each side) located under the operator’s seat. WARNING Do not ride the motorcycle with a helmet in the helmet holder.
Instruments and Controls Instrument Cluster The instrument cluster includes the speedometer, the tachometer, the indicator lights, and the multi- -function display. Speedometer The speedometer reports current motorcycle speed in miles per hour or kilometers per hour. Tachometer The tachometer reports current engine speed in revolutions per minute (RPM).
Instruments and Controls The low oil pressure indicator also illuminates when the ignition switch is in the On position and the engine is not running. This demonstrates that the indicator is functioning properly. Low Fuel Indicator illuminates when approximately 0.8 gallons (3.03 liters) of fuel remains.
Instruments and Controls Multi- -Function Display (MFD) Use the MFD to view the odometer, the trip odometer, the clock, the fuel gauge, the voltmeter, the instrument cluster light dimmer, the headlamp high beam indicator light dimmer, and the check engine indicator. The MFD operates only when the ignition switch is in the On position.
Instruments and Controls Clock A clock icon appears as part of the display when in clock mode. When the clock is operating normally, the colon between the hour and minutes flashes. To set the clock, the ignition switch must be in the On position with the MFD in clock mode. 1.
Instruments and Controls Instrument Cluster Light Dimmer “DIM” appears as part of the display when in instrument cluster light dimmer mode. To change the intensity of the instrument cluster light, press the MFD Set button to select from six (6) intensity levels. The engine does not need to be running to change the light intensity.
Instruments and Controls Check Engine Indicator The check engine indicator will flash “CH ENG” any time the the ignition switch is in the On position and the Engine Control Module sensors report abnormal sensor or engine operation. The check engine indicator will continue to flash as long as the fault condition exists.
Page 52
Instruments and Controls DEFAULT ODOMETER TRIP ODOMETER CLOCK SET 3 Sec SET 3 Sec SET 3 Sec FLASHING FLASHING FLASHING METRIC/ RESET TRIP HOURS DIGIT TEN--MINUTE DIGIT MINUTES DIGET ENGLISH ODOMETER INCREASE INCREASE INCREASE VALUE VALUE VALUE ALTERNATOR/ BACK LIGHTING HIGH BEAM DIMMER FUEL BATTERY...
Instruments and Controls Left Side Handlebar Controls Fast Idle Lever The fast idle lever increases the engine idle speed when starting a cold engine (see page 60). To engage the fast idle lever, move the lever toward the rear of the motorcycle until the lever stops. Headlamp High/Low Beam Switch The headlamp high/low beam switch toggles the headlamp between high beam, low beam, and...
Instruments and Controls Clutch Lever To disengage the clutch, pull the clutch lever toward the handlebar. To engage the clutch, gradually release the clutch lever. For smooth clutch operation, pull the lever quickly and release it gradually. The motorcycle is equipped with a clutch interlock switch that prevents the engine from starting Notice when the transmission is in gear and the clutch is engaged (see page 62).
Instruments and Controls Emergency Flasher Switch The emergency flasher switch activates and cancels the emergency flashers. When the emergency flashers are active, all of the turn signals flash. To activate the emergency flashers, slide the switch to the left; to cancel the flashers, slide the switch to the right. Starter Button To engage the engine starter motor, press the right side of the starter button.
Instruments and Controls Gear Shift Pedal The gear shift pedal is located on the left side of the motorcycle. To shift to a lower gear, press down on the front of the gear shift pedal. To shift to a higher gear, press down on the rear, or lift up on the front, of the gear shift pedal.
Saddlebags are included on some Victory models. For loading and operating speed information regarding models with saddlebags, see “Safety Precautions,” page 13. Leather saddlebags are included with the V92C Deluxe Cruiser. The load carrying capacity for leather saddlebags is 7 lbs. (3.2 kg) each.
Instruments and Controls Sidestand The sidestand is located on the left side of the motorcycle. WARNING Correctly retract the sidestand before operating the motorcycle. The sidestand could come into contact with the ground and cause you to lose control of the motorcycle. To extend the sidestand, swing it out from the end until it is fully extended.
Pre-Operation Check To keep your Victory motorcycle in good working order, make the checks described in this section before each ride. This is especially important before you make a long trip or when you remove the motorcycle from storage. You must be familiar with the Victory motorcycle instruments and controls to make these checks. You can find additional service information in the Maintenance section of the Owner’s Manual, in the Victory Service Manual, or from an authorized Victory dealer.
Pre-Operation Check Pressing the MFD Mode button should advance the MFD through the various functions (see page 34). Headlamp Check the headlamp to see that it is on. Set the headlamp switch to the high beam position. The headlamp brightness should increase and the headlamp high beam indicator in the instrument cluster should illuminate. Taillight With the ignition switch in the On position, the taillight and the license plate light should illuminate.
Pre- -Operation Check Engine Stop/Run Switch Be sure the engine stop/run switch stops the engine, or prevents the engine from starting when set to the Stop position. If you regularly use this switch to shut off the engine, you are already checking its operation each Notice time you use the motorcycle.
Pre-Operation Check WARNING Do not operate the motorcycle with the oil level above the FULL mark or below the ADD mark. Operating the engine with too much or too little oil can cause serious engine damage or engine seizure, resulting in you losing control of the motorcycle. Fuel Check Fuel Level 1.
Normal riding warms the tires and increases the tire air pressure. For an accurate reading, check the tire pressure before you ride. Adjust tire pressure as required for the total weight of your intended load. Tire Pressure Table V92C Standard Cruiser Up to 200 lbs (91 kg) load 200--475 lbs (91--215 kg) load...
Pre-Operation Check Check Tire Condition Inspect the tire sidewalls, road contact surface, and tread base for cuts, punctures, and cracking. Replace damaged tires immediately (see your Victory Service Manual or an authorized Victory dealer). Check Tread Depth Raised areas at the base of the tread, known as wear bars; act as easily visible tread depth indicators.
Pre- -Operation Check Check Front Brake Fluid Level 1. To check the front brake fluid level, rest the motorcycle on the sidestand and on level ground. Turn the handlebars until the front brake fluid reservoir is level. 2. View the brake fluid through the sight glass. The fluid should be clear and at a level in or above the sight glass.
Pre-Operation Check Check Rear Brake Fluid Level 1. To check the rear brake fluid level, remove the right side cover. Straddle the motorcycle and bring it to a vertical position. 2. View the brake fluid through the reservoir. The fluid should be clear and at a level between MIN and MAX.
Pre- -Operation Check Check Throttle Control Grip and Cables 1. Rotate the throttle control grip. It should rotate smoothly from its rest position to its completely open position and 1/8--1/4 inch back again. It should return to its rest position quickly (3--6 mm) when released.
Pre-Operation Check Check Fast Idle Lever 1. Move the fast idle lever. It should move smoothly from its rest position to its completely open position and back again 2. Fast idle lever freeplay - - the amount of lever movement from the rest position to the point of cable resistance - - should be 1/8- -1/4 inch (3- -6 mm).
Pre- -Operation Check Check Steering Straddle the motorcycle and bring it to a vertical position. Turn the handlebars from stop to stop. The action should be smooth but not loose or interfered with by wires, hoses, or control cables. Check Rear Suspension Proper rear suspension adjustment is essential for a safe and comfortable ride.
Pre-Operation Check Check Sidestand Straddle the motorcycle and bring it to a vertical position. Move the sidestand to its stored (up) position, then to its fully extended (down) position, and back again. It should move smoothly and quietly. When the sidestand is in its stored position, the sidestand return spring should hold the sidestand tightly against the motorcycle.
Operation This section describes how to operate the Victory motorcycle for best performance and longevity, including: Engine Break- -in Period Fueling And Fill Height Starting The Engine Shifting Gears Accelerating Braking Stopping The Engine Parking For safe operation and riding, see Safety Precautions, beginning on page 3. Engine Break- -in Period During the first 500 miles (800 kilometers), critical engine parts require special wear- -in procedures so they seat and mate properly.
Operation Engine Break- -in Period (continued) 0- -90 miles (0- -145 kilometers) - - Do not operate the motorcycle for extended periods of time at throttle positions above 1/3 throttle. Vary the engine speed of the motorcycle. Do not operate the motorcycle for extended periods of time at any one set throttle position.
Operation Fueling and Fill Height Fuel the motorcycle with the sidestand down and on level ground. Use only the recommended fuel (see “Fuel Specifications” page 137). Fill the fuel tank to a level just below the bottom of the fuel filler insert. WARNING •...
Operation Starting the Engine The Victory motorcycle has a starter interlock system. The engine can be started only when the transmission is in neutral, or when the transmission is in gear and the clutch is disengaged. Follow these steps to start the motorcycle: 1.
Page 75
Operation Starting the Engine (continued) 7. Leaving the throttle closed, press and hold the starter button until the engine starts. If the engine does not start within a few seconds after you press the starter button, release the button and wait several seconds. Then press and hold the starter button again. Hold the starter button for as short a time as possible to minimize battery drain, and do not push the starter button for more than 10 seconds at any one time.
Operation Shifting Gears WARNING The clutch must be fully disengaged (clutch lever pulled completely in toward the handlebars) before you attempt to shift gears. Forced shifting (shifting without the clutch disengaged) may damage the engine, transmission, and drive train, causing you to lose control of the motorcycle. The motorcycle is equipped with a five- -speed transmission.
Page 77
Operation Shifting Gears (continued) To engage first gear, start the engine (see “Starting the Engine” page 60). With the engine at idle speed, engage the front brake (squeeze the brake lever) and disengage the clutch (squeeze the clutch lever). Push the shift pedal down until you feel it stop in first gear.
Operation Shifting Gears (continued) WARNING • Downshifting at a speed in excess of the recommended downshift point may severely damage the transmission or cause the rear wheel to lose traction. It could also result in engine damage from running at excessive rpm. Reduce speed before downshifting and do not downshift at a speed above that in the table of recommended shift points.
Operation Accelerating To accelerate, open the throttle (roll the throttle control grip toward you). For even acceleration, open the throttle with a smooth, continuous motion. When you reach the recommended speed for upshifting, shift up one gear according to the instructions in “Shifting Gears” page 62. The more quickly you open the throttle, the more quickly the motorcycle accelerates.
Operation Braking To slow the motorcycle with the brakes, close the throttle and apply the front and rear brakes evenly. As the motorcycle slows, either disengage the clutch or downshift each time your speed reaches a downshift point. Applying slightly more front brake than rear brake generally gives you the best braking performance. Do not apply the brakes so forcefully or quickly that either wheel stops rotating.
Operation Stopping the Engine Before stopping the engine, bring the motorcycle to a complete stop either in neutral or with the clutch disengaged. Once the motorcycle is at a complete stop, if it is not already in neutral, shift into neutral. To stop the engine, set the engine stop/run switch to the Stop position, turn the ignition switch to the Off position, and remove the ignition key.
Page 82
Operation Parking (continued) If you must park on a slope, point the motorcycle toward the top of the slope. Put the transmission in gear and park the motorcycle so that it is stable when it rests on the sidestand. If you must park on a soft surface, use a sidestand plate under the foot of the sidestand to provide a firm surface.
Maintenance This section includes information for maintaining your Victory motorcycle. It also includes recommended periodic maintenance intervals. “Periodic maintenance” means performing the regular service required to keep your motorcycle in top working condition. Regular service increases motorcycle durability, safety, and dependability, and provides greater riding pleasure.
Maintenance Initial Maintenance Perform the initial maintenance after you’ve ridden your new motorcycle 500 miles (800 kilometers). This maintenance is one of the most important services your motorcycle requires and should be performed by an authorized Victory dealer. Initial maintenance includes servicing all adjustments, tightening all fasteners, and changing engine oil.
Maintenance Engine Oil Change Engine Oil and Oil Filter This procedure involves using a small automotive style oil filter wrench. 1. Start and run the engine until it reaches normal operating temperature. Stop the engine. 2. Securely support the motorcycle on the sidestand. 3.
Maintenance 10. Reinstall the oil fill cap and then start and run the engine until it reaches normal operating temperature. Caution After an oil change, the low oil pressure indicator remains illuminated longer than usual before going out. Revving the engine while the low oil pressure indicator is illuminated can damage the engine. 11.
Maintenance WARNING Do not operate the motorcycle with the oil level above the FULL mark or below the ADD mark. Operating the engine with too much or too little oil can cause serious engine damage or engine seizure, resulting in you losing control of the motorcycle. Inspect Air Filter The standard Victory air filter element is a dry paper design and does not require the use of air filter oil.
Maintenance Inspect Drive Sprocket and Sprocket Nut 1. Remove the drive sprocket cover. On some models it may be necessary to remove portions of the exhaust system to access all of the Notice drive sprocket cover screws (see the Victory Service Manual or an authorized Victory dealer). 2.
Maintenance Check Drive Belt Tension This procedure involves using the belt tension gauge, part no. PV- -43532, which is designed specifically for measuring drive belt tension. Before beginning this procedure: Make sure the drive belt is dry and at room temperature. Make sure the rear suspension is properly adjusted (see 1.
This position represents 10 lbs. force. 6. Calculate the difference between the zero force position and the 10 lbs. force position you recorded. V92C Standard and Deluxe Cruiser: 5/16 inch (8.0 mm) 7. Adjust belt tension as necessary.
Maintenance WARNING Do not reuse a cotter pin because it may fail, allowing the wheel to loosen and you to lose control of the motorcycle. 6. Pump rear brake several times to reset brake pad distance. Align Rear Wheel This procedure involves using the rear wheel alignment tool, part no. PV- -43528, which is designed specifically for aligning the rear wheel.
Page 95
Maintenance 6. To adjust the rear wheel alignment, remove and discard the rear axle cotter pin and loosen the rear axle castle nut. Loosen the rear axle adjuster jam nuts. 7. Turn the axle adjuster on the side with the longer measurement counterclockwise one flat (1/6 revolution).
Maintenance Rear Suspension Adjust Rear Shock Absorber The distance measured while the motorcycle is Notice elevated will not change, and needs only be measured once. After the measurement and the locations from where the measurement is taken is recorded (steps 1- -4), you will only need to perform steps 5- -8 in the to correctly adjust the rear shock absorber.
Page 97
Maintenance 5. Load the motorcycle with all the things you intend to carry (cargo and accessories). Sit in the operator’s seat with your riding gear on, and if you plan on carrying a passenger, have them sit in the passenger seat with their riding gear on. 6.
Maintenance Inspect Swing Arm and Rear Axle 1. Remove the swing arm pivot covers and tighten the swing arm pivot nut. Torque: 85 ft- -lbs (115 Nm) 2. Reinstall the pivot nut covers. 3. Sit in the operator’s seat and slowly bounce the rear suspension a few. Make sure the suspension moves freely without binding.
Maintenance Front Suspension and Steering Check Front Forks 1. To check the front suspension, straddle the motorcycle and bring it to a vertical position. 2. Apply the front brake and push down hard on the handlebars several times. The front suspension should operate smoothly and quietly.
Maintenance Inspect Steering and Front Axle 1. Elevate the front of the motorcycle until the front wheel is off of the ground. Use an appropriate motorcycle lift or a block of wood or steel placed securely under the frame. 2. Turn the handlebars from stop to stop. The action should be smooth but not loose or interfered with by wires, hoses, or control cables.
Maintenance Check Crankcase Ventilation Hose and Connections Remove the operators seat and fuel tank. Inspect the crankcase ventilation hose for cracks or damage. Inspect the hose connection at the air cleaner and at the crankcase for dampness or stains from leaking. Evaporative Emission Control System (California models only) Visually inspect all evaporative emission control system hoses and connections.
Maintenance 8. Reinstall the fuel tank mounting screws. Torque: 20 ft- -lbs (27 Nm) 9. Reinstall the operator’s seat. Replace Fuel Filter The fuel filter is attached to the electric fuel pump located inside the fuel tank. Fuel filter condition is associated with engine performance and fuel economy.
Maintenance Throttle Check Throttle Control Grip and Cable 1. Rotate the throttle control grip. It should rotate 1/8--1/4 inch smoothly from its rest position to its completely open (3--6 mm) position and back again. It should return to its rest position quickly when released.
Maintenance Clutch Check Clutch Lever and Cable 1. Squeeze the clutch lever toward the handlebar and release it. It should move freely and smoothly and should return to its rest position quickly when released. 2. Clutch freeplay - - the amount of clutch lever movement from the rest position to the point of cable resistance - - should be between 0.04- -0.08 inch (1- -2 mm).
Maintenance 10. Reconnect the clutch cable and reinstall the clutch lever, lever pivot screw, and nut. Torque: 40 in- -lbs (5 Nm) 11. Adjust clutch freeplay. Adjust Clutch Freeplay 1. Remove the operator’s seat. 2. Remove the front and rear fuel tank screws. 3.
Maintenance Lubricate Control Cables The following cables used on the motorcycle require periodic lubrication for smooth operation and longevity: Throttle Cables Clutch Cable Fast Idle Lever Cable Seat Release Cable 1. Loosen the adjuster of the cable to be lubricated, and disconnect one end of the cable. 2.
Maintenance Lubricate Front Brake Lever 1. Remove brake lever pivot nut and pin. 2. Remove any old grease and dirt from the brake lever and lever housing. 3. Lubricate the brake lever and lever pivot pin with Victory All Purpose Grease or equivalent. 4.
Page 108
Maintenance Caution Brake fluid attacks painted surfaces and plastic parts. Always clean spilled brake fluid immediately with plenty of water and a mild detergent. WARNING • Do not operate the front brake while its reservoir cover is removed. Fluid could overflow from the reservoir and cause air to enter the fluid system.
Maintenance Check Rear Brake Pedal Freeplay and Movement Rear brake pedal freeplay - - the amount of brake pedal movement from the rest position to the point of contacting the master cylinder - - should be 3/16- -5/16 inch (5- -8 mm). Adjust 3/16--5/15 inch pedal freeplay as necessary (see page 95).
Maintenance Check Rear Brake Fluid Level 1. To check the rear brake fluid level, remove the right side cover. Straddle the motorcycle and bring it to a vertical position. 2. View the brake fluid through the reservoir. The fluid should be clear and at a level between MIN and MAX. Add brake fluid if necessary.
Maintenance WARNING • Do not operate the rear brake while its reservoir cover is removed. Fluid could overflow from the reservoir and cause air to enter the fluid system. Air in the brake fluid system could cause the brakes to malfunction. •...
Maintenance Check Brake Hoses and Connections Inspect all brake hoses and connections for dampness or stains from leaking or dried fluid. Tighten any leaking connections and replace components as necessary. Gear Shift Pedal Adjust Gear Shift Pedal Height 1. Loosen the gear shift linkage rod locknuts. 1.
Normal riding warms the tires and increases the tire air pressure. For an accurate reading, check the tire pressure before you ride. Adjust tire pressure as required for the total weight of your intended load. Tire Pressure Table V92C Standard Cruiser Up to 200 lbs (91 kg) load 200--475 lbs (91--215 kg) load...
(1.6 mm). 1. Tread Depth Gauge Check Wheel Spokes (V92C Deluxe Cruiser) Inspect both wheels for loose, bent, broken, or missing spokes. To identify loose spokes, grasp each spoke and try to move it side to side or up and down. All spokes should be equally tight and have the same amount of flex.
Maintenance Check or Replace Spark Plugs The spark plugs must be removed from the engine to inspect them. Spark plugs with bright white deposits, sooty black deposits, or with damaged insulators or electrodes can indicate engine problems. If these conditions exist, or if the condition of one plug is markedly different from the other, see the Victory Service Manual or an authorized Victory dealer for assistance.
Page 116
Maintenance 5. Remove the spark plug from the cylinder head with a spark plug socket. Both spark plugs should have the same light or medium tan color deposits on the insulator around the electrode tip. The spark plug electrode tip and bridge 0.032 inch should have sharp, square edges.
Maintenance Check Engine Compression An accurate periodic engine compression check documents engine wear and condition. For engine compression check procedures and special tools required, see the Victory Service Manual or contact an authorized Victory dealer. Check Exhaust System Check the exhaust system for stains from leaking exhaust gasses. Replace exhaust gaskets if necessary (see the Victory Service Manual or an authorized Victory dealer).
Maintenance Remove and Install Seats The V92C Standard and Deluxe Cruiser have two separate seats - - the operator’s seat and the passenger’s seat. WARNING Always make sure the seats are securely locked before riding the motorcycle. An unlocked seat could cause a sudden shift in riding position, causing you to lose control of the motorcycle.
Maintenance Battery The motorcycle uses a permanently sealed, maintenance- -free battery. Do not remove the battery cap strip for any reason. Keep the battery connections clean and tight at all times. WARNING The battery contains sulfuric acid, which can cause severe burns. Do not allow sulfuric acid to contact skin, eyes, or clothing.
Maintenance Remove Battery 1. Remove the left side cover. 2. Remove the battery hold- -down strap. 3. Disconnect the negative ( - - ) battery cables (exposed connectors). 4. Disconnect the positive ( + ) cables (covered with a red boot). Caution Disconnecting the positive cable first can produce an electric shock that could result in damage or injury.
Maintenance 1. To clean oxidation from the battery posts and cable connectors, use a wire brush. Wash the posts and cable connectors with a solution of 1 part baking soda to 16 parts water. Rinse with clean water and wipe dry. Apply a thin film of dielectric grease to the posts and cable connectors. 2.
Maintenance Electrical Equipment Replace Fuses Caution Use only recommended amperage fuses or you can damage the electrical system. 1. Remove the operator’s seat and the right side cover. 2. Release the tabs on each side of the fuse box cover, and remove the cover. 3.
Maintenance Adjust Headlamp The headlamp should shine straight ahead of 25 feet (7.62 m) the motorcycle. The top of the headlamp High beam should be just below the center of the lamp at a distance of 25 feet (7.62 m). 1.
Maintenance Remove and Install Saddlebags V92C Deluxe Cruiser 1. Remove the screws, washers, and spacers from inside the saddlebag, and remove the saddlebag from the motorcycle. 2. To reinstall the saddlebag, return all spacers and fasteners to their original location and tighten.
Maintenance 2. Move the sidestand to its stored (up) position and remove the sidestand return spring. WARNING Wear face protection. The sidestand return spring is under tension and can injure your eyes and face when released. 3. Remove the sidestand pivot bolt. 4.
Maintenance Check Fasteners Visually inspect the entire motorcycle chassis and engine for loose, damaged, or missing fasteners. Tighten loose fasteners to the proper torque (see the Specifications section of the Owner’s Manual, or the Victory Service Manual). Replace stripped, damaged, or broken fasteners with genuine Victory fasteners of equal size and strength immediately.
Cleaning and Storage This section explains how to properly clean the various parts of your Victory motorcycle and how to store it to keep it in good working order and appearance. Cleaning Clean your motorcycle regularly to protect it from corrosion and to keep it looking new. As you clean your motorcycle you perform a complete and thorough visual inspection that may reveal components in need of repair.
Cleaning and Storage Washing and Drying Before washing the motorcycle, make sure the exhaust pipes are not hot. Cover each exhaust pipe opening with a plastic bag and attach the bag to the pipe with a strong rubber band. To prevent contamination from water, check that the spark plugs, spark plug wire caps, oil fill cap, and fuel caps are properly seated.
Page 129
Cleaning and Storage Caution Use as little water as possible when washing near the air cleaner or the exhaust pipe openings. An excessively wet air cleaner, or water in the exhaust pipes, may cause the engine to start and run poorly. Dry these components thoroughly before using the motorcycle.
Cleaning and Storage Waxing, Polishing, and Applying Protectants (Items Other Than Windshields and Leather Saddlebags) After washing and drying the motorcycle, you can help extend the life and appearance of its components by waxing painted surfaces, polishing chrome surfaces, and applying a protectant to exposed rubber, vinyl, and plastic parts.
Cleaning and Storage Windshield Care A windshield is included with some Victory models. Wash the windshield using a soft cloth or sponge soaked in a solution of mild detergent and warm water, applying minimal pressure as you wash. Let the detergent do the cleaning, not the pressure you apply. Excessive washing pressure may cause dirt, sand, or other foreign materials on the windshield to scratch it.
Cleaning and Storage Caring for natural leather is similar to caring for your own skin. To prevent leather from becoming hard and dry, occasionally apply a leather conditioner. A good quality leather conditioner replaces the natural oils lost by repeated exposure to sun, wind, and rain. Leather subject to drier climates will require more frequent conditioning.
Cleaning and Storage This section includes instructions for preparing the motorcycle for storage, maintaining it during storage, and removing it from storage. Preparing for Storage Choose an adequate storage location Choose a dry, well- -ventilated storage location, inside a garage or other structure if possible. The location should have a firm, flat surface and allow enough space for the motorcycle.
Cleaning and Storage Protect Engine Components 1. Change the engine oil (see “Change Engine Oil and Oil Filter” page 74). You do not need to replace the oil filter at this time, but you must replace the oil filter when you remove the motorcycle from storage.
Cleaning and Storage Remove, Clean, and Store Battery 1. Remove the battery (see “Remove Battery” page 106). 2. To clean oxidation from the battery posts and cable connectors, use a wire brush. Wash the posts and cable connectors with a solution of 1 part baking soda to 16 parts water. Rinse with clean water and wipe dry.
Cleaning and Storage Removing from Storage 1. Remove the cover and unlock the front forks. 2. Check the tire pressure and inflate the tires if necessary. 3. Reinstall the battery (see “Install Battery” page 107). 4. Wash and dry the entire motorcycle (see “Washing and Drying” page 114). 5.
Warranties Motorcycle Noise Regulation Tampering with noise control systems is prohibited. Federal law prohibits the following acts or causing thereof: The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement, of any device or element of design incorporated into any new vehicle for the purpose of noise control prior to its sale or delivery to the ultimate purchaser or while it is in use, or The use of the vehicle after such device or element of design has been removed or rendered inoperative by any person.
Victory dealer or Victory Motorcycle Division, Polaris Sales Inc., P.O. Box 47700, Hamel, MN 55340- -9960 Emissions Control System Warranty Victory Motorcycles, Polaris Sales Inc. - Emission Control System Warranty Statement Your Warranty Rights and Obligations The California Air Resources Board and Victory Motorcycle Division, Polaris Sales Inc. (hereinafter Victory) are pleased to explain the emission control system warranty on your 2002 or later Victory motorcycle.
Warranties Manufacturer’s Warranty Coverage Class III motorcycles (280 cc and larger): for a period of use of five (5) years or 30,000 kilometers (18,641 miles), whichever first occurs. If an emission-related part on your motorcycle is defective, the part will be repaired or replaced by Victory. This is your emission control system DEFECTS WARRANTY.
Warranties Victory Motorcycle Division, Polaris Sales Inc., (hereinafter Victory) warrants that each new 2002 and later Victory Motorcycle that includes as standard equipment a headlight, taillight and stoplight, and is street legal: A. is designed, built and equipped so as to conform at the time of initial retail purchases with all applicable regulations of the United States Environmental Protection Agency, and the California Air Resources Board;...
Warranties failure occurs prior to the first scheduled replacement; and hoses, clamps, fittings and tubing used directly in these parts. Since emission related parts may vary from model to model, certain models may not contain all of these parts and certain models may contain functionally equivalent parts. In the State of California only, Emission Control System emergency repairs, as provided for in the California Administrative Code, may be performed by other than an authorized Victory dealer.
Warranties B. Inspections, replacement of parts, and other services and adjustments necessary for required maintenance C. Any motorcycle on which the odometer mileage has been changed so that actual mileage cannot be readi- ly determined. III. Limited Liability A. The liability of Victory under this Emission Control System Warranty is limited solely to the remedying of defects in material or workmanship by an authorized Victory motorcycle dealer at its place of business dur- ing customary business hours.
Warranties IV. Legal Rights THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE. V. This Warranty Is In Addition To The Victory Limited Motorcycle Warranty. VI. Additional Information. Any replacement part that is equivalent in performance and durability may be used in the performance of any maintenance or repairs.
If you have not signed the original registration and received the “customer copy”, please contact your dealer immediately. NO WARRANTY COVERAGE WILL BE ALLOWED UNLESS YOUR VICTORY MOTORCYCLE IS REGISTERED WITH VICTORY MOTORCYCLES DIVISION OF POLARIS SALES INC. Initial dealer preparation and set-up of your Victory Motorcycle is very important in ensuring trouble-free operation.
THE REMEDIES SET FORTH IN THIS WARRANTY ARE THE ONLY REMEDIES AVAILABLE TO ANY PERSON FOR BREACH OF THIS WARRANTY. VICTORY MOTORCYCLES DIVISION OF POLARIS SALES INC. SHALL HAVE NO LIABILITY TO ANY PERSON FOR INCIDENTAL, CONSEQUENTIAL...
Page 146
Please work with your dealer to resolve any warranty issues. Should your dealer require any additional assistance they will contact the appropriate person at Victory Motorcycles division of Polaris Sales Inc. This warranty also gives you specific legal rights, and you may also have other rights which vary from state to state.
Specifications Model Year 2002 V92C Standard Cruiser V92C Deluxe Cruiser Dimensions Overall Length 94 in (239 cm) 94 in (239 cm) Overall Width 29.5 in (75 cm) 41 in (104 cm) Overall Height 44.5 in (113 cm) 58.5 in (149 cm) Seat Height 29.5 in (75 cm)
Page 148
Specifications Model Year 2002 V92C Standard Cruiser V92C Deluxe Cruiser Engine Engine Model Number MCVT1507D 2002 MCVT1507D 2002 Configuration 50_ V-Twin 50_ V-Twin Displacement 92 cu in (1507 cc) 92 cu in (1507 cc) Cooling System Air & Oil Air & Oil Compression Ratio 9.2:1...
Page 149
Specifications Model Year 2002 V92C Standard Cruiser V92C Deluxe Cruiser Internal Gear Ratios 3.2:1 3.2:1 2.19:1 2.19:1 1.53:1 1.53:1 1.24:1 1.24:1 Final Drive Ratio 2.13:1 2.13:1 Clutch Type Wet Multi-Disk Wet Multi-Disk Diaphragm Spring Diaphragm Spring Drive Belt Deflection 5/16 inch (8.0 mm) 5/16 inch (8.0 mm)
Page 150
Specifications Model Year 2002 V92C Standard Cruiser V92C Deluxe Cruiser Wheels and Tires Front Wheel Type/Size Cast 5 Spoke Laced 40 Spoke 16 x 3 in 16 x 3 in Rear Wheel Type Size Cast 5 Spoke Laced 40 Spoke 16 x 3.5 in...
Specifications Fuel Specifications Use only unleaded gasoline, 92 pump octane minimum. DO NOT USE GASOLINE CONTAINING METHANOL. Using gasoline/methanol blends can result in poor starting and drivability, and may damage critical fuel system components. Gasoline containing up to 15% Methyl Tertiary Butyl Ether (MTBE) can be used. Gasoline containing up to 10% Ethanol can be used.
Page 156
Index Evaporative emission control system. See Emission Front forks control system Checking, 85 Location, 24 Exhaust gases, safety, 16 Maintenance intervals, 71 Exhaust system Oil replacement intervals, 71 Checking, 103 Front tire. See Tires Location, 25 Front turn signals. See Turn signals Maintenance intervals, 73 Front wheel.
Page 157
Index Fuel system Checking crankcase ventilation hose and connec- Hazardous materials, handling, 69 tions, 87 Headlamp Checking hoses and connections, 86 Adjustment, 109 Fuel tank removal and installation, 87 Checking operation, 46 Maintenance intervals, 71 High beam indicator light, 33 Fuses High/low beam switch Location, 25...
Page 158
Index Ignition key Location, 32 Function, 29 Information labels, 19–23 Identification number, 27 Instrument cluster Ignition switch Description, 32 Function, 30 Location, 23 Location, 24 Instrument cluster light dimmer (MFD), 36 Off position, 30 Instruments and controls, 29–44 On position, 30 Introduction, 1–3 Park position, 31 Seat release, 31...
Need help?
Do you have a question about the V92C and is the answer not in the manual?
Questions and answers
Can I use 89 octane in my v92s