Scheduled Maintenance Services (Diesel Engine) - SSANGYONG 2010 Kyron User Manual

SCHEDULED MAINTENANCE SERVICES (DIESEL ENGINE)

Maintenance service and record retention are the owner's responsibility. You should retain evidence that proper maintenance
0
has been performed on your vehicle in accordance with the scheduled maintenance service chart.
1
MAINTENANCE
2
MAINTENANCE
3
ITEM
4
ENGINE CONTROL SYSTEM
Drive belt
5
* Engine oil & filter *1
(1)* (3)* (4)*
6
7
Cooling system hose & connections
Engine coolant (3)* (4)*
8
* Fuel filter Direct Injection
(Diesel Engine)
9
Additional water separator (if equipped)
Fuel line & connections
10
Air cleaner (2)*
11
12
Injection timing (See NOTE 1)
NOTE 1: Adjust as required;
13
Chart Symbols:
I - Inspect these items and their related parts. If necessary, correct, clean,
14
replenish, adjust or replace.
*1 Check the engine oil level and leak every 3,000 km (2,000 miles) or
15
before starting a long trip.
R - Replace or change.
(1)* If vehicle is operated under severe condition:
16
Shorten the service interval.
- Frequent stop-and-go traffic, extended idling, short driving distance below 6 km,
driving distance below 16 km when the outside temperature remains below freezing
13-36
SERVICE AND MAINTENANCE
* EU Countries: Only countries that belong to EU. (It does not apply to all countries in EU.)
x1,000 km
INTERVAL
x1,000 miles
Months
EU Initial check: 5,000 km, and replenish if necessary, change every 15,000 km or 12 months
General
EU
General Replace every 25,000 km (Draining water from fuel filter: whenever replacing the engine oil)
Replace every 150,000 km or 5 years (Drain the water whenever replacing the engine oil)
EU
General
- When excessive smoke is visible (black or white)
- Poor performance/economy
Kilometers (miles) or time in months, whichever comes first
15 30 45
10 20 30
12 24 36
I I I
(But, shorten the service interval under severe conditions)
Initial change: 5,000 km, change every 10,000 km or 12 months
(But, shorten the service interval under severe conditions)
I I I
Change every 200,000 km or 5 years. And, inspect and replenish if necessary.
I R* I
I I I
Initial clean: 5,000 km, clean every 15,000 km, replace every 30,000 km
(But, shorten the service interval under severe conditions)
Initial clean: 5,000 km, clean every 10,000 km, replace every 30,000 km
(But, shorten the service interval under severe conditions)
I I I
(2)* If vehicle is operated under severe condition, driving in dusty con-
(3)* More frequent maintenance is required if under dusty driving
(4)* Refer to "Recommended fluids, coolant and lubricants".
* Water separator: When replace the engine oil, also drain the water from
the fuel filter.
* Use only approved
Ssangyong genuine parts.
60 75 90
40 50 60
48 60 72
I I I
I I I
R* I R*
I I I
I I I
- Driving in a hilly or mountainous terrain, sandy, or dusty area
- High load driving such as trailer towing
- Taxi, patrol service or delivery service (extended idling and
excessive driving with low speed)
dition or sandy condition, pollutant area or off-road driving, fre-
quently inspect the air cleaner, if necessary, change the air cleaner.
condition.
105 120
70 80
84 96
I I
I I
I R*
I I
I I