Scheduled Maintenance Services (Diesel Engine) - SSANGYONG KYRON User Manual

SCHEDULED MAINTENANCE SERVICES (DIESEL ENGINE)

Maintenance service and record retention are the owner's responsibility. You should retain evidence that proper maintenance
has been performed on your vehicle in accordance with the scheduled maintenance service chart.
MAINTENANCE
x1,000 km
INTERVAL
MAINTENANCE
x1,000 miles
ITEM
ENGINE CONTROL SYSTEM
Drive belt
* Engine oil & filter EU
(1)* (3)* (4)* General
Cooling system hose & connections
Engine coolant (3)* (4)*
* Fuel filter EU
Direct Injection
(Diesel Engine) General
Additional Water Separator (if equipped)
Fuel line & connections
Air cleaner (2)* EU
General
Injection timing (See NOTE1)
NOTE 1: Adjust as required; - When excessive smoke is visible (black or white)
- Poor performance/economy
Chart Symbols:
I - Inspect these items and their related parts. If necessary, correct, clean,
replenish, adjust or replace.
R - Replace or change.
(1)* If vehicle is operated under severe condition:
- Frequent stop-and-go traffic, extended idling, short driving distance
below 6 km, driving distance below 16 km when the outside tempera-
ture remains below freezing
- Driving in a hilly or mountainous terrain, sandy, or dusty area
- High load driving such as trailer towing
Page 35
* EU Countries: Only countries that belong to EU. (It does not apply to all countries in EU.)
Kilometers (miles) or time in months, whichever comes first
15 30 45
10 20 30
Months 12 24 36
I I I
Initial check: 5,000 km, and replenish if necessary, change every 15,000 km or 12 months
Initial change: 5,000 km, change every 10,000 km or 12 months
I I I
Change every 60,000 km or 3 years. And, inspect and replenish if necessary.
I R* I
Replace every 25,000 km (Draining water from fuel filter: whenever replacing the engine oil)
Replace every 150,000 km or 5 years (Drain the water whenever replacing the engine oil)
I I I
Initial clean: 5,000 km, clean every 15,000 km, replace every 30,000 km
(But, shorten the service interval under severe conditions)
Initial clean: 5,000 km, clean every 10,000 km, replace every 30,000 km
(But, shorten the service interval under severe conditions)
I I I
(2)* If vehicle is operated under severe condition, driving in dusty con-
(3)* More frequent maintenance is required if under dusty driving
(4)* Refer to "Recommended fluids, coolant and lubricants".
* Water separator: When replace the engine oil, also drain the water from
the fuel filter.
SERVICE AND MAINTENANCE
* Use only approved
Ssangyong genuine parts.
60 75 90
40 50 60
48 60 72
I I I
I I I
R* I R*
I I I
I I I
- Taxi, patrol service or delivery service (extended idling and ex-
cessive driving with low speed)
Shorten the service interval. Inspect the engine oil at any time,
occasionally, if necessary refill the engine oil.
dition or sandy condition, pollutant area or off-road driving, fre-
quently inspect the air cleaner, if necessary, change the air cleaner.
condition.
2006-10-03, ¿ÀÈÄ 2:36
0
1
2
105 120
70 80
3
84 96
4
I I
5
6
I I
7
I R*
8
9
I I
10
11
12
I I
13
14
15
16
13-35