Cushman 632904 Service Manual page 147

Read all of Section B and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
MODEL: SHUTTLE™ 8
TYPE: ELECTRIC POWERED PERSONNEL CARRIER
MODEL YEAR: 2012
Part No:. 626500
Precision Drive System™ (PDS):
Solid State continuously variable seperately excited speed controller
Dash mounted direction selector switch (Forward-Neutral-Reverse)
Anti-roll back, walkaway braking and alarm
Anti-stall motor protection
Regenerative 'Pedal Down' and/or 'Pedal Up' braking
Battery Charger: Delta Q, 48 VDC. H120/230 VAC 50/60 Hz. Underwriters Laboratories (U.L.) Listed, (C.S.A. Certified)
Motor: 48 volt DC shunt wound, brazed armature, solid copper windings. Intermittant Horsepower 18.1 hp (13.5 kW) at 1900 rpm (1hour)
Drive Train:
Direct motor shaft connected to transaxle pinion shaft
Electrical System: 48 Volt DC, eight, 6 volt deep cycle storage batteries (107 minute, 225 amp-hour @ 20 hr. discharge rate)
Transaxle: Differential with helical gears
Brakes: 4 Wheel Hydraulic Brakes, Front Disk, Rear Drum, Floor Mounted Manual set/released Park Brake w/ Warning Buzzer
Dimensions
Overall Length
Overall Width
Overall Height (No Canopy)
Overall Height (With Canopy) 76.0 in (193 cm)
Wheel Base
Front Wheel Track
Rear Wheel Track
Gnd Clearance @ Differential 4.3 in (11 cm)
Vehicle Power
Power Source
Motor Type
Continuous Horsepower (kW) 2.5 hp (1.9 kW)
Intermittent Horsepower (kW) 18.1 hp (13.5 kW) @ 1900 rpm
Electrical System
Batteries (Qty, Type)
Key or Pedal Start
Battery Charger
Speed Controller
Drive Train
Transaxle
Gear Selection
Rear Axle Ratio
Noise & Vibration
Noise Sound pressure; continued A-weighted equal to or less than 70 db(A)
Vibration, WBV The RMS value of weighted acceleration is less than 2.5 m/s
Vibration, HAV The RMS value of weighted acceleration is less than 2.5 m/s
The uncertainty of measurement is 0.69 m/s
Measurement methods were applied per the ISO 2631 and ISO 5349 standards under conditions of typical vehicle surfaces.
2012 Shuttle 8 E
Released: 01/12/2012
Revised: 01/12/2012
PRODUCT SPECIFICATION
CONFIGURATION HIGHLIGHTS
Factory programmable to application
PRODUCT OVERVIEW
167.5 in (425.5 cm)
49.5 in (125.7 cm)
45.5 in (115.6 cm) (Top of steering wheel)
123.4 in (313.7 cm)
36.0 in (91.4 cm)
38.0 in (97 cm)
48 Volts DC
Shunt Wound
48 Volt
Eight, 6 Volt Deep Cycle
Pedal Start
48 VDC Delta Q, 120/230 VAC, UL & CSA
400 Amp Precision Drive System (PDS)
Motor Shaft Direct Drive
Differential with helical gears
Dash Mounted Forward-Neutral-Reverse
14.7:1
Some items shown may be optional equipment
Specifications are subject to change without notice
* Field installed accessories may require installation charges
Repair and Service Manual
GENERAL SPECIFICATIONS
Eight, 6 Volt Deep Cycle
Full torque, reduced speed reverse
Inductive throttle sensor
Diagnostic indicator
Performance
Seating Capacity
Seating Capacity option
Dry Weight
Curb Weight
Cargo Deck Capacity
Vehicle load capacity
Outside Clearance Circle 33 ft (10.1 m)
Speed (Level Ground)
Towing Capacity
Steering & Suspension
Steering
Front Suspension
Rear Suspension
Service Brake
Parking Brake
Front Tires
Rear Tires
Body & Chassis
Headlights
Brake Lights
Frame
Body & Finish
Seat Pod
Standard Color
2
2
2
8 Person using Flip/Flop (base config)
6 Person using Cargo Deck w/ stake side
1142 lb (519 kg) (Without Batteries)
1632 lb (742 kg)
400 lb.
1600 lb (727 kg)
13 mph ± 0.5 mph (21 kph ± 0.8 kph)
N/A
Self-compensating rack and pinion
Leaf springs with hydraulic shock absorbers
Leaf springs with hydraulic shock absorbers
4 Wheel hydraulic Brakes, Disk/Front, Drum/Rear
Floor Mounted Manual Set/Release w/Warning Buzzer
Kenda Load Star, 50 psi
Kenda Load Star, 70 psi
Halogen Headlights std
Rear Brake lights std
Welded steel. DuraShield™ powder coat
Injection molded TPO
Fiberglass & Gelcoat
Hunter Green
B
B
Page R-1