Ezgo 605586 Repair And Service Manual page 184

TROUBLESHOOTING
Read all of Section B and this section before attempting any procedure. Pay particular attention to all Notes, Cautions and Warnings.
B
Condition
STARTER ROTATES BUT VEHICLE
WILL NOT START OR HARD TO
START
Page S-2
Possible Cause
Weak Battery
Corroded or loose battery connections
Check for adequate fuel level
No spark at spark plugs. Broken or
disconnected spark plug wiring
Spark plugs fouled
Broken or disconnected coil wires
Faulty ignitor
Faulty pulser unit
Incorrect spark plug gap/type
Fuel pump faulty
Fuel line clogged or clamp loose
Cracked or broken fuel line
Main jet blocked
Throttle lever motion restricted
Dirt or water in fuel line or carburetor
Clogged fuel filter
Incorrect carburetor float settings
Engine flooded
Engine fuel starved
Air intake tube is blocked
Clogged air filter
Plugged muffler or pipe
Low compression in engine
Repair and Service Manual
Correction
Recharge or replace as necessary
Clean and tighten battery connections.
Apply a coat of battery protectorate to
terminals
Fill with correct grade gasoline to 1"
(2.5 cm) below bottom of filler neck
Check and replace if required
Clean or replace
Check or replace
Check or replace
Check or replace
Set gap correctly
Repair or replace
Clean or replace if required
Replace with new hose
Clean jet
Check all linkages
Clean lines and carburetor. Replace filter
Check and replace if required
Adjust float level - check seats
Push choke in. Clean/or replace spark
plugs
Use choke and push in as soon as engine
runs smoothly
Repair or clean
Wash or replace as required
Repair or replace
Check and repair