Ezgo 605586 Repair And Service Manual page 183

Read all of Section B and this section before attempting any procedure. Pay particular attention to all Notes, Cautions and Warnings.
GASOLINE VEHICLE PERFORMANCE
Condition
STARTER DOES NOT TURN
STARTER TURNS SLOWLY
Possible Cause
Weak or bad battery
Terminals are loose or corroded
Poor wiring connections
Faulty Ignition Switch
Blown fuse
Solenoid faulty
Accelerator micro switch
Starter/generator terminals are loose or
corroded
Leads are broken or faulty ground
Field coils are open
Armature coil is open
Terminals are loose or corroded
Weak battery
Leads are nearly broken or connections
are faulty
Mechanical problem inside
starter/generator
Internal engine damage
Crankcase over filled with oil
Repair and Service Manual
TROUBLESHOOTING
Correction
Recharge or replace as necessary
Clean and retighten
Repair or replace wire and/or connections
Repair or replace wire and/or connections
Investigate cause and replace fuse
If no audible 'click' is heard, check power
and ground. Replace solenoid if power
and ground is good
Check and adjust if no 'click' is heard.
Replace if adjustment does not work
Tighten or clean
Check for breaks at bend or joint.
Replace or repair leads
Repair or replace
Repair or replace
Retighten or clean
Charge battery
Check for any defect of leads at bend or
joint. Replace leads or repair connections
Check
Inspect and repair
Drain and fill to recommended level with
approved oil
Page S-1