Superior DRL6542TEN Installation And Operation Instructions Manual page 58

Innovative Hearth Products
Superior DRL6000 Series Direct-Vent Gas Fireplaces
TM
Installing the glass door
1. Visually inspect the gasket on the backside of the glass door.
2. While holding the glass door by the sides, hook the top edge onto the fireplace, and swing the bottom of the
3. Align the screw holes below the glass door with the holes in the fireplace, and secure using the three (3)
4. Install the modesty panel (Page 43).
Removing the glass door
1. Remove the modesty panel (Page 43).
2. Remove the three (3) screws beneath the door (Figure 56).
3. Swing the bottom of the glass door away from the fireplace to a 45° angle.
4. Carefully grip the door at the top and bottom, and remove it from the fireplace. Place the door in a safe location
Figure 56: Glass Door
Rating plate and lighting instructions
are attached to door bracket.
Installing the Optional Bezel
1. Hook the bezel upper flange over the top edge of the glass door and swing the lower edge of the bezel toward the
2. Gently push the lower edge of the bezel to attach the bezel lower flange to the lower edge of the glass door
58
NOTE: The gasket surface must be clean, free of irregularities, and seated firmly. Ensure it is properly located.
Make sure the bead is not rolled into the channel at the top of the door, but remains flat against the top of
the glass.
glass door gently in towards the fireplace ensuring that the gasket seats evenly as the door draws shut.
NOTE: If the lower flange of the door does NOT clear the lower front frame of the fireplace, ensure the door
UPPER mounting flange is completely and properly engaged on the fireplace frame BEFORE INSERTING THE
SCREWS. Proper door alignment and sealing are important to the operation and performance of the fireplace.
Ensure the door seal is contacting the frame and that no air leaks are present.
provided screws (Figure 56).
for later reinstallation.
Glass Door
door (Figure 56).
(Figure 56).
Figure 57: Bezel
Bezel
Lower
Flange
[CROSS-SECTION]
Operation
900077-00, 03/2014
Bezel
Upper
Flange
Glass
Door
Frame