Checking Rear Brake Fluid Level; Adding Brake Fluid To The Rear Brake Circuit - KTM 450 SX-F EU Repair Manual

13/BRAKE SYSTEM
Guideline
Nut, loot brake lever stop
- Hold push rod and tighten nut
Guideline
Remaining nuts, chassis
- Reconnect spring
Checking rear breke lIuid lavel
Warning
Danger of accidents Failure of the brake system.
MB
M6
20 Nm
(14.B Ibl
It)
15 Nm
(11.1
Ibf
It)
- II the brake fluid level falls below the MIN mark, this indicates a leakage in the brake system or worn-out brake linings.
Check the brake system and do not continue riding.
Warning
Danger of accidents Reduced braking efficiency due to old brake fluid.
- Change the brake fluid of the front and rear brake according to the service schedule.
- Stand the vehicle upright.
- Check the brake Iluid level in the sight glass
• If there is an air bubble in the sight glass visible:
- Add brake fluid to the rear brake circuit. (-- p. 104)
Adding breke lIuid to tile rear brake circuit
Warning
Danger of accidents Failure of the brake system.
- If the brake fluid level falls below the MIN mark, this indicates a leakage in the brake system or worn-out brake linings.
Check the brake system and do not continue riding.
Warning
Skin irritation Brake fluid can cause skin irritation on contact.
- Avoid contact with skin and eyes, and keep out of the reach of children.
- Wear suitable protective clothing and goggles.
104
- If brake fluid comes into contact with the eyes, flush the eyes thoroughly with water and consult a physician immediately.
Warning
Dan,,, of accidents Reduced braking efficiency due to old brake fluid.
- Change the brake fluid of the front and rear brake according to the service schedule.
Warning
Environmental hazard
Hazardous substances cause environmental damage.
- Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.
• Info
I
Never use DOT 5 brake fluid! It is silicone-based and purple in color. Oil seals and brake lines are not designed for DOT 5
brake fluid.
Avoid contact between brake fluid and painted parts. Brake fluid attacks paint!
Use only clean brake fluid from a sealed container.