Troubleshooting; Blown Fuse Or Circuit Breaker; Gate Does Not Open; Gate Does Not Open Or Is Sluggish. Agitator Turns - Cornelius 2230 C4-100 Manual

IMPORTANT: Only qualified personnel should service internal components of electrical wiring.
WARNING: Disconnect electrical power to unit before attempting any electrical repairs to
internal components. if repairs are to be made to CO
plain water and CO
before proceeding.
Should your unit fail to operate properly, check that there is power to the unit and that the hopper con-
tains ice. If the unit does not dispense, check the following chart under the appropriate symptoms to aid
in locating the defect.

BLOWN FUSE OR CIRCUIT BREAKER.

GATE DOES NOT OPEN.

GATE DOES NOT OPEN OR IS SLUGGISH.
AGITATOR TURNS.

GATE OPENS. AGITATOR DOES NOT TURN

ICE DISPENSES CONTINUOUSLY.

SLUSHY ICE. WATER IN HOPPER.

91748

TROUBLESHOOTING

supplies then disconnect syrup tanks and bleed systems pressures
2
Trouble
, syrup or plain water systems, shut off
2
Probable Cause
A. Short circuit in wiring.
B. Defective gate solenoid.
C. Defective agitator motor.
A. No power.
B. Bent depressor plate (does not actuate switch).
C. Defective dispensing switch.
D. Blown/defective fuse or jammed gate solenoid.
A. Defective gate solenoid.
B. Excessive pressure against gate slide.
C. Weak gate spring.
A. Ice solidified in hopper.
B. Defective agitator motor.
C. Defective capacitor.
D. Defective agitation timer.
A. Stuck or bent depressor plate (does not
release switch).
B. Defective dispensing switch.
C. Improper switch installation.
A. Blocked drain.
B. Unit not level.
C. Poor ice quality due to water quality or
icemaker problems.
D. Improper use of flaked ice.
12