Table Of Contents - Heat & Glo RED40-N-AU Owner's Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
A. Congratulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
B. Limited Lifetime Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1 Listing and Code Approvals
A. Appliance Certifi cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
B. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . . 8
C. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 8
D. Non-Combustible Materials Specifi cation. . . . . . . . . . . . . . 8
E. Combustible Materials Specifi cation . . . . . . . . . . . . . . . . . 8
F. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
User Guide
2 Operating Instructions
A. Gas Fireplace Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
B. Your Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
C. Clear Space . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
D. Decorative Doors and Fronts . . . . . . . . . . . . . . . . . . . . . . 10
E. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
F. Decorative Media Options . . . . . . . . . . . . . . . . . . . . . . . . 10
G. Remote Controls, Wall Controls and Wall Switches . . . . . 10
H. Before Lighting Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . 10
I. IPI Battery Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
J. Lighting Instructions (IPI) . . . . . . . . . . . . . . . . . . . . . . . . . 11
K. Control Module Operation . . . . . . . . . . . . . . . . . . . . . . . . 12
L. After Fireplace is Lit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
M. Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . 13
3 Maintenance and Service
A. Maintenance Tasks-Homeowner . . . . . . . . . . . . . . . . . . . 14
B. Maintenance Tasks-Qualifi ed Service Technician . . . . . . 15
4 Getting Started
Installer Guide
A. Typical Appliance System. . . . . . . . . . . . . . . . . . . . . . . . . 16
B. Design and Installation Considerations . . . . . . . . . . . . . . 17
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . 17
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . 17
5 Framing and Clearances
A. Selecting Appliance Location . . . . . . . . . . . . . . . . . . . . . . 18
B. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 19
C. Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
D. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 21

Table of Contents

Heat & Glo • RED40-N-AU, RED40ST-N-AU • 2294-900 Rev. G • 7/14
6 Termination Locations
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 22
7 Vent Information and Diagrams
A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
B. Vent Table Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
C. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
D. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

E. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
8 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 31
B. Wall Penetration Framing . . . . . . . . . . . . . . . . . . . . . . . . . 31
C. Install the Ceiling Firestop . . . . . . . . . . . . . . . . . . . . . . . . 32
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 33
9 Appliance Preparation
A. Appliance Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
B. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 35
C. Active Convection Technology . . . . . . . . . . . . . . . . . . . . . 36
10 Installing Vent Pipe (DVP Pipe)
A. Assemble Vent Sections. . . . . . . . . . . . . . . . . . . . . . . . . . 37
B. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 38
C. Secure The Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . 38
D. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 39
E. Install Decorative Ceiling Components . . . . . . . . . . . . . . 39
F. Install Metal Roof Flashing . . . . . . . . . . . . . . . . . . . . . . . . 40
G. Assemble and Install Storm Collar . . . . . . . . . . . . . . . . . . 40
H. Install Vertical Termination Cap . . . . . . . . . . . . . . . . . . . . 41
I. Heat Shield Requirements for Horizontal Termination . . . 41
J. Install Horizontal Termination Cap . . . . . . . . . . . . . . . . . . 41
11 Gas Information
A. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . 42
B. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
12 Electrical Information
A. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
B. Junction Cord Information . . . . . . . . . . . . . . . . . . . . . . . . 45
C. IntelliFire Plus™ Ignition System Wiring . . . . . . . . . . . . . 45
D. Electrical Service and Repair . . . . . . . . . . . . . . . . . . . . . . 46
E. IPI Plus Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . 47
F. Active Convection Blower Replacement . . . . . . . . . . . . . 48
G. Control Module Operation . . . . . . . . . . . . . . . . . . . . . . . . 51
3