Replacement Part List - SCAN DSA 4 Instructions For Installation And Use Manual

4. Clean the area where the glass and gasket are to be installed.
5. Install the new flat self-adhesive gasket on the edge of the inside surface of the outer door
frame around the opening and cut off surplus gasket to make a tight joint.
(The side with the adhesive adhere the gasket to the inside of the outer door frame).
6. Carefully place the glass on the outer door frame and install the inner door frame using the
screws previously removed. Hold the parts together and install the screws only two turns.
Install the flat part of the P-gasket oriented so it will fit between the outer door frame and the
inner door frame. (When installing the P-gasket cord, use your fingers or a screwdriver to push
the flat part of the gasket under the inner door frame. Make sure the gasket is not pushed in so
far that the round part will not seal against the door opening of the stove.)
Gradually and evenly tighten the inner door frame screws in an alternating pattern around the
frame (enough to be sure the door gasket stays in place), then fully tighten the screws.
7. Carefully turn around the door and install the tube gasket between the glass and the outer
door frame with your fingers.
8. Install the door on to the fireplace again in reverse order of disassembly (see under 1).
Make sure to maintain the same distance between the door edges and the insert on both sides
and that the door and the latch work properly.
6.6

Replacement part list:

Caution: Use only original SCAN DSA 4 replacement parts. Do not use substitute materials.
Description
Glass Panel
Gasket, Tadpole – 5.75 ft. Door Seal
Gasket, .25 in. Rnd - 5 ft. / Interior Glass seal
Gasket, Flat – 5 ft. / Exterior Glass seal
Door Latch Pawl
Pin, Smoke Baffle Supports
Upper Smoke Baffle w Edge Guard
Lower Smoke Baffle
Smoke Baffle Set, w/ support pins
Side Panel, Skamol
Rear Panel, Skamol
Combustion Panel Set, Sides & Rear
Bottom Fire Brick, L & R
Bottom Fire Brick, Center
Firebrick Set, Complete
Primary Air Valve Kit, Black
Primary Air Valve Kit, Gray
Replacement Door, Black
Replacement Door, Black
Surround Clip & Leg Levelers
Part Number
223885
223948
129644
K5521200007
222805
223049
157098
223888
157054
223887
223889
157052
223891
223890
157053
157092
1157093
157046
157046
157071
16