Section 4 Maintenance And Adjustment Of Electrical Appliance; (I)Inspection Of Battery - ATV ATV110-M Service Manual

Section 4 Maintenance and Adjustment of Electrical Appliance

-34-

(I)Inspection of battery

Warning:
The electrolyte is dangerous article, whitch in-
cludes sulphuric acid, so it is poisonous and
corrosive.
.Please operate by the following steps:
a.Avoid the body touching the electrolyte so as
to protect the eye from burn or damage.
b.Wear the protective glasses when operating
near the battery.
.Avoiding measures(External):
a.Wash the skin with water.
b.Wash the eyes for 15 minutes with water, then
conduct treatment at hospital.
.Avoiding measures (Internal):
Drink a plenty of water , magnesia oxide, egg
and rapeseed oil, and conduct treatment as early
as possible.
.The battery can produce explosive gas, so fol-
low the following protection measures:
a.Be sure to keep the ventilation when changing
the battery.
b.Keep it away from spark, flame,(such as weld-
ing equipment, burning cigarette, etc).
c.Smoking is strictly prohibited when charging
or operating the battery to keep the battery and
electrolyte away from children.
1.Removal (Refer to the content of Section Two
of this chapter.)
.Cut off
Refter to "Removal of cushion"of this chapter.
Battery electrode (negative electorde¢Ù,positive
electrode)
Warning
First remove the negative electrode
2.Removal:
a.Battery clamp plate ¢Ü
b.Battery clamp plate ¢Û
Caution
Before using a new battery, be sure to charge
to ensure the best condition of the vehicle.
3.Inspection of battery electrode
If the dirt is found, clean off with brush.
If it is not connect well , correct it.
Caution
After cleaning the electrode, apply a film of lu-
brication grease.