Inspection Service - Volkswagen FOX 2004 Service Manual

2.6

Inspection Service

Service based on time or kilometers traveled
Vehicles with "Service based on time or kilometers traveled" have
the PR numbers: QG0.
Inspection intervals
Vehicles with service depending on time or kilometers traveled,
every 30,000 km or 2 years and every 60,000 km or 4 years (for
Europe on vehicles model ▸2007).
Vehicles with service depending on time or kilometers traveled,
every 60,000 km or 3 years and, then, every 2 years (for Europe
on vehicles model 2008▸ , except Europe on vehicles 2009▸) .
Vehicles with service depending on time or kilometers traveled,
every 1 year, 30,000 km, and 60,000 km (except Europe for ve‐
hicles model ▸2008).
If the vehicle runs 30.000 km, 60.000 km, etc. before elapsing 1
year, the Inspection Service for 30,000 km, 60,000 km, etc. shall
be performed together with the inspection service for 1 year.
If the vehicle runs 30.000 km or 60.000 km after the performance
of the Inspection Service for 1 year, perform only the items ex‐
clusive for the Inspection Service for 30,000 km or 60,000 km.
A tolerance of "up to 1,000 km" is acceptable, above or below the
indicated kilometer traveled, in services based on kilometers trav‐
eled, and "one month", after or before the indicated time, for
services based on time.
Note
Inform the customer in case of problems within a service scope
♦
that require a Repair action.
Use oils with high lubrication performance according to spec‐
♦
ifications VW 502 00 (petrol) and VW 505 00 or 505 01 (SDI),
(diesel PD) and VW 505 01 (TDI).
For countries with high sulfur content in Diesel, the Engine Oil
♦
Change Service must be carried out every 7500 km. Countries
where the sulfur content is higher
Notes for carrying out tasks
The sequence of each service operation was tested and opti‐
mized. It shall be adhered to so as to prevent unnecessary service
interruptions.
If the battery is disconnected, the power window drive automatic
closing function will not operate. Thus, this function must be re‐
programmed before delivering the vehicle. The vehicle battery
cannot be disconnected after reprogramming. Power window
drive - reprogram ⇒ page 36
Ask the customer about installing new Windshield wiper blades
and adding window cleaning -G 052 131 A1- until 07/2005 and
window cleaning -G 052 184 A2- until 08/2005 or cleaning and
antifreeze product -G 052 164 A1- to the Windshield/rear window
wiper system.
Application
EUROPE only
Tropical climate countries
⇒ page 28 .
.
Windshield/rear window washer
additive
-G 052 164 A1- or -G 052 164 A2- 300 ml of additive for 700 ml of wa‐
-G 052 131 A1- until 07/2005
FOX 2004 ➤
Maintenance - Edition 07.2010
Proportion
ter.
1.69 fl oz additive for 28.74 fl oz wa‐
ter.
2. Service plans
13