Remove Door Hinges; Door Seal - GE Monogram ZBD6400 Series Technical Service Manual

6000 & 7000 Series DISHWASHERS
5.2.10.3 Return the door to a partially closed position as
shown in the photograph below to prevent damage to the
spillway fixed to the front lip of the stainless steel tub.
5.2.10.4 With the Swing Arms of the door hinges returned to
the door open position, lift the stainless steel door liner clear
of the dishwasher as shown below.
Door liner to near closed position
Hinge swing
arms to door
open position
5.2.11 To remove Door Hinges from Tub Side Plate.
5.2.11.1 Remove the door hinge springs and support rods.
5.2.11.2 Remove the inner door liner.
5.2.11.3 Lever the speed clip from the door hinge pivot stud.
(The clip will be damaged in this operation and will need to be
replaced). Slide the door hinge out from the tub and lift clear.
Inner Door Liner Speed Clip
Hinge Pivot Stud
Lever Spring Support Rod
Lever
5.2.11.4 Reassemble the dishwasher in reverse order.
5.2.11.5 Operate and test dishwasher before leaving.

5.2.12 Door seal

CAUTION. Switch off electrical power supply
and turn off water supply at main or isolating
valve.
To correctly hold the door seal in position a channel is formed
by a plastic seal retainer screwed to the front opening in the
tub. The retainer runs up the inside surface of the tub, across
the roof, then down the other side.
5.2.12.1 To remove the door seal grasp the bottom section of
the seal near the door hinge and pull it out from the seal
retainer starting from the LHS around the tub to the RHS.
5.2.12.2 When refitting the door seal, begin by positioning
the seal in the bottom of the retainer on the LHS as shown
below.
Seal retainer
Door Seal
5.2.12.3 Then refit the seal into the retainer up the LHS,
across the roof, then down the RHS. Ensure the door seal sits
in the retainer correctly with the seal lip facing to the inside of
the tub and has no puckering around the top corners of the
tub.
5.2.12.4 Operate and test dishwasher before leaving.
CAUTION. Test for water leaks before leaving.
PAGE 40