Troubleshooting Flow Chart - Kohler COMMAND CV17-745 Service Manual

Kohler Engine Parts Call K&T 606-678-9623 or 606-561-4983
Section 5B
EFI Fuel System
Code: 56 "32 Pin" (MSE 1.1) Plastic-
Cased ECU only.
Source: Fuel pump relay circuit open, shorted
to ground, or shorted to battery
Explanation: Fuel pump, ignition coils, and fuel
injectors will not function because the
fuel pump relay circuit is either open,
shorted to ground, or may be "on"
continuously if shorted to battery.
Expected Engine
Response: Engine will not run, or fuel pump will
continue to run when switch is off.
Possible Causes:
1. Fuel Pump Relay Related
a. Bad fuel pump relay.
Primary side open or shorted.
2. Fuel Pump Related
a. Fuel pump open or shorted internally.
3. Engine Wiring Harness related
a. Fuel pump fuse F1 open.
b. Broken or shorted wire in harness.
ECU pin 28 to fuel pump relay pin 86.
Ignition switch to fuel pump relay pin 85.
4. ECU Related
a. Circuit controlling fuel pump relay damaged.
5B.38
Code:
Source:
Explanation:

Troubleshooting Flow Chart

The following flow chart provides an alternative
method of troubleshooting the EFI system. The chart
will enable you to review the entire system in about 10-
15 minutes. Using the chart, the accompanying
diagnostic aids (listed after the chart), and any
signaled fault codes, you should be able to quickly
locate any problems within the system.
www.mymowerparts.com
61
Denotes the end of fault codes. If
signaled first, no other fault codes
are present.