Maintenance; Air Filters; Empty The Condensate Tank And Reset The Alarm - KwiKool KPHP Series Operation Manual

SECTION VII - MAINTENANCE
A. AIR FILTERS
The KwiKool System comes from the factory with filters installed on the evaporator inlet to
prevent dust and debris from entering the system and circulating in the conditioned space.
Factory installed filters are a disposable type and must be periodically checked and replaced
based on the air quality of the conditioned space.
The air filter is located on the front of the KwiKool System below the control.
1. Remove the access door by turning the slotted lock fastener counter-clockwise and pull
to open.
2. Remove and replace the filter.
3. Return the door to its designated location and turn the slotted fastener clockwise until
snug.
B. EMPTY THE CONDENSATE TANK AND RESET THE ALARM
Follow these steps to empty the tank and reset the alarm.
1. Remove the float switch jack by pulling it straight back, then remove the condensate bot-
tle by pushing the front of the bottle slightly downward and then pull the bottle out.
2. Remove the cap threaded onto the bottle by turning it counterclockwise.
3. Empty the collected water.
4. Put the cap on the bottle by turning it clockwise, taking care not to cross thread the cap
upon installation.
5. Tighten the cap to the point where the angle connector on the condensate bottle lines up
with the nipple extending out from the drain pan on the KwiKool System and insert the
bottle by pushing down slightly to clear the extended drain pan nipple. Be sure the drain
pan nipple is inside of the angle connector and the cap is snug and not cross threaded to
avoid water leakage.
6. Install the float switch jack by pushing it straight in and confirm the pin is fully inserted or
the alarm will not clear.
7. Continue normal operation.
CAUTION
Failure to maintain the filters will cause restricted
air flow and can lower overall unit performance.
PRUDENCE
Le fait de ne pas entretenir les filtres entraînera un
débit d'air restreint et peut réduire les performances
globales de l'unité.
21