Safety Procedures; Safety At Work; General - probst JM-VARIO-200-B Operating Instructions Manual

Safety
2.6

Safety procedures

2.7

Safety at work

2.7.1 General

•
Working with this device is only permitted in proximity to the ground.
The sucked load must never be lifted more than 1.8 m (measured from the top edge of the
load to the ground). Swinging the device over persons is prohibited. Danger to life!
•
The manual guiding of is only allowed for devices with handles.
•
The operator is not allowed to leave the control unit as long as the vacuum lifting device loaded with
load (stone slab). The load must always be in the range of vision of the operator.
•
Always keep an eye on the vacuum gauge. Never lift loads when the vacuum is below the required
under pressure (mbar). If the pointer of the pressure gauge moves into the red danger zone, lower
the load immediately! Danger! Load could fall down!
•
While using the vacuum lifting device is the stay of persons in the working area forbidden. Except it
is indispensable. Caused of the way of using the vacuum lifting device , e.g. if the device must be
leaded by hand.
•
While using the vacuum lifting device be sure that there are no persons in the working area. Danger
to Life!!
•
The device must never be subjected to a force acting in a lateral direction due to diagonal pulling.
•
Do not lift any components off-centre, because that could fall down. Danger of tilting!
•
Release the load only when it is completely safely resting on the surface. Keep fingers away from
the load when you release it as they can be crushed!
•
The carrying capacity / working load limit (WLL) and the nominal width the vacuum lifting device
must not be exceeded.
•
Do not pull out stuck or tightened loads with the device.
The jerky raising or lowering of the device with or without load is prohibited!
Unnecessary vibrations must be avoided. Just like driving fast with the carrier/ hoist over uneven terrain!
Danger to life: Load could fall off or load handling equipment could be damaged!
In general, only drive at walking speed with the load lifted!
52000029 / 52000029-150 / 52000029-200 10 / 37 GB