Section 11 − Parts List; Recommended Spare Parts - Miller Big Blue 600 Air Pak Owner's Manual

E. Air Compressor
Trouble
Air compressor does not operate; no air
pressure at air shutoff valve.
Air compressor stops after short period
of operation.
Low air pressure.
High air pressure.
Pneumatic tools freeze up because of
moisture in compressed air.
Oil in air from compressor.
Oil in compressor air cleaner.
11-1.

Recommended Spare Parts

Dia.
Mkgs.
. . . . . . . . . . . . . . . . . . . . 276418
. . . . . . . . . F1, F2 . . . 085874
. . . . . . . . . . . . . . . . . . . . 190823
. . . . . . . . . . . . . . . . . . ♦192939
. . . . . . . . . . . . . . . . . . . . 262459
. . . . . . . . . . . . . . . . . . . . 192938
. . . . . . . . . . . . . . . . . . . . 255765
. . . . . . . . . . . . . . . . . . . . 255764
. . . . . . . . . . . . . . . . . . . . 067265
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . 265120
. . . . . . . . . . . . . . . . . . . . 279121
. . . . . . . . . . . . . . . . . . . . 206745
. . . . . . . . . . . . . . . . . . . . 197676
. . . . . . . . . . . . . . . . . . . . 206747
. . . . . . . . . . . . . . . . . . . . 276620
. . . . . . . . . . . . . . . . . . . . 253944
♦Optional
.
Complete Parts List available at www.MillerWelds.com
Place Air Compressor switch in On position. The air compressor will not start if still under pressure. If
compressor is turned off, wait for air pressure to bleed off (about 60 seconds) before turning compressor
on again.
Reset supplementary protector CB15 (see Section 9-4).
Check compressor belt tension. Be sure correct belt is used and is properly installed.
Verify secondary air/oil filter is not plugged. Replace air/oil separator.
Have Factory Authorized Service Agent check Air Compressor switch S10, control relay CR10, air pres-
sure switch S11, temperature switch S12, compressor control circuit, and air compressor clutch.
Check compressor oil level (see Section 9-5). Automatic shutdown stops compressor if compressor tem-
perature is too high.
Clean debris from radiator. Automatic shutdown stops compressor if compressor temperature is too high.
Check for leaks in air lines and hoses.
Adjust compressor air pressure (see Section 9-6).
Check air compressor air cleaner (see Section 9-3).
Have Factory Authorized Service Agent check compressor for rated output.
Adjust compressor air pressure (see Section 9-6).
Be sure control line is connected at regulator valve and inlet valve.
Install optional air dryer/filter kit (Part No. 195117).
Check compressor oil level (see Section 9-5). If oil level is too high, system becomes saturated with oil.
Change compressor air/oil separator (see Section 9-5).
Check connections of control lines (see air compressor circuit diagram in Section 12).
Have Factory Authorized Service Agent check for blocked separator scavenge check valve/filter orifice.
Have Factory Authorized Service Agent verify compressor inlet valve is operating properly.
SECTION 11 − PARTS LIST
Part
No.
. . USB Flash Drive
. . Fuse, Mintr Cer Slo-blo 10. Amp 250 Volt
. . Brush, Contact Elect .250 X.500 X 1.250 Grd Ay
. . Filter, Air Element Safety
. . Kit, Filters Deutz (2.9l4) Engine (Includes)
. . . . Filter, Air Element Primary
. . . . Filter, Fuel Secondary
. . Filter, Fuel Pri
. . . . Oil Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery, Stor 12v 925 Crk 195 Rsv Gp 31 Maint Free
. . Belt, V 1/2 X 5/16 X 52 (Big Blue 800 Duo Pro)
. . Filter Kit, Ingersoll Rand (Ce55 G1) (Air Pak Models) (Includes)
. . . . Filter, Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Element, Air Cleaner
. . . . Separator, Oil/Air Filter
. . . . Oil, Air Compressor (Quart)
. . Belt, Micro-v 8 Rib (Air Pak Models)
Remedy
Description
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
OM-279640 Page 73
Quantity
1
2
3
1
1
1
1
1
1
1
1
1
1
4
1