Appropriate Use - HADEF 238/10-EX Installation, Operating And Maintenance Instruction

This is especially important for operating personnel that rarely uses the equipment, i.e. for installation or
maintenance work.
DANGER!
In order to avoid severe injury, please pay attention to the following when using the equipment:
 Use protective clothes/equipment.
 Do not wear long hair hanging down open.
 Do not wear rings or other jewelry.
 Do not wear clothes that are too big/wide.
 Do not reach into ropes, chains, drive parts or other moving parts with your hands
2.4

Appropriate use

The permitted safe working load of the devices must not be exceeded! An exception can be made during the
load test before initial operation, carried out by a licensed qualified person.
 Defective devices and load suspension devices must not be used until they have been repaired! Only
original spare parts must be used. Non-compliance will result in any warranty claims becoming void.
 Liability and warranty will become void if unauthorized modifications of the units are made by the user!
 The permissible ambient temperature when operating the devices: -20°C/+70°C )*
) * At an atmospheric pressure range from 0.8bar to 1.1bar and an oxygen content of approx. 21%
DANGER!
The permissible ambient temperature must not be exceeded!
Vertical lifting and lowering of unguided loads, horizontal movement of loads and inclined movement of
loads, movement of flaps, covers etc.
2.4.1 Winches with disengaging clutch (as option)
 Only for pulling out the uncharged wire rope
 Only for horizontal load
 Only for special kinds of use (i.e. lowering of floaters in liquids) when there is no danger for persons or
danger of damage of material.
DANGER!
It's only allowed to use the unit in the EX-classification which is named on the type plate; or in lower
classes.
NOTICE!
If the units are not used appropriately, it is not possible to ensure safe operation.
The owner and operator have sole liability for all personal injury and damage to property arising from
inappropriate use.
DANGER!
Use is not allowed:
 Pulling loose of stuck loads, dragging of loads and inclined pulling.
 The use in an area at risk from explosion. Exception is made when the unit is modified to be explosion-
proof and this is shown on special type plates it carries for this purpose.
 In reactor containment.
 To transport people with the equipment.
 To hold lifted loads.
 For usein stages or studios.
 Persons must not stand under a suspended load.
5.52.208.01.01.02 5