Requirements For The Operating Personnel; Appropriate Use - HADEF 43/86P Liftboy-EX Installation, Operating And Maintenance Instruction

 The required personal protective equipment for the operators, service and repair personnel is available
and is used.
 The operating instructions are always available at the location where the equipment is used and that they
are legible and complete.
 The unit is only operated, serviced and repaired by qualified and authorized personnel.
 This personnel is regularly trained in all applicable matters regarding safety at work and environmental
protection, and that they are familiar with the operating manual and, in particular, the safety instructions it
contains.
 Any safety and warning signs on the devices are not removed and remain legible.
 customers equipment at site must comply with currently applicable ATEX-regulations
WARNING!
It is not allowed to make constructive changes of the equipment!
2.3

Requirements for the operating personnel

The units may only be operated by qualified persons that are appropriately trained and that are familiar with
it. They must have their employer's authorization for operation of the units.
Before starting work, the operating personnel must have read the operating and installation instructions,
especially the chapter "Safety Instructions".
This is especially important for operating personnel that rarely uses the equipment, i.e. for installation or
maintenance work.
DANGER!
In order to avoid severe injury, please pay attention to the following when using the equipment:
 Use protective clothes/equipment.
 Do not wear long hair hanging down open.
 Do not wear rings or other jewelry.
 Do not wear clothes that are too big/wide.
 Do not reach into ropes, chains, drive parts or other moving parts with your hands
2.4

Appropriate use

The permitted safe working load of the devices must not be exceeded! An exception can be made during the
load test before initial operation, carried out by a licensed qualified person.
 Defective devices and load suspension devices must not be used until they have been repaired! Only
original spare parts must be used. Non-compliance will result in any warranty claims becoming void.
 Liability and warranty will become void if unauthorized modifications of the units are made by the user!
 The permissible ambient temperature when operating the devices:
Type of drive
Manually driven
Motor driven
) * At an atmospheric pressure range from 0.8bar to 1.1bar and an oxygen content of approx. 21%
) ** Devices of this category have been specially modified and labeled by the manufacturer
DANGER!
The permissible ambient temperature must not be exceeded!
Vertical lifting and lowering of unguided loads, horizontal movement of loads and inclined movement of
loads, movement of flaps, covers etc. up to the maximum rated load.
DANGER!
It's only allowed to use the unit in the EX-classification which is named on the type plate; or in lower
classes.
5.52.289.01.01.04
Device classification for
not explosive atmosphere
-20°C/+50°C
-20°C/+40°C
Explosive atmosphere
)* )**
according to ATEX
-20°C/+40°C
-20°C/+40°C
5