INFORMATION ABOUT MAINTENANCE
5.4
KDI TCR Tier 4 final – Stage IIIB – Stage IV- Stage V
KDI TCR/D Tier 3 – Stage IIIA
(1) - In case of low use: 12 months.
(2) - The period of time that must elapse before checking the filter element depends on the environment in which the
engine operates. The air filter must be cleaned and replaced more frequently under very dusty conditions.
(3) - In case of low use: 36 months.
(4) - The inspection must be carried out every 50 hours or every week in engines with an ATS system (
(6) - Contact authorized KOHLER workshops.
(7) - The replacement interval is only an indication, it strongly depends from environmental condition and hose status
detected during regular visual inspection.
(8) - The first check must be done after 10 hours.
(9) - Test the coolant condition annually with coolant test strips.
(10) - It is recommended to have SCA (Supplemental Coolant Additives) added at the first maintenance interval.
5.3 Oil level check
Important
•
Before proceeding with operation, read
•
Do not use the engine with the oil level below the minimum.
1. Remove the oil dipstick B and check that the level is up to MAX
.
2. Pour in recommended oil until reaching the MAX level mark.
3. Reinstall the oil dipstick B completely..
4. Re-tighten the cap A and/or C (Fig. 5.2) .
5.4 Air filter check
NOTE : Components not supplied by KOHLER .
Refer to the technical documentation of the vehicle..
5.5 Check of the radiator heat - exchanger surface
NOTE : Components not supplied by KOHLER .
Refer to the technical documentation of the vehicle..
FUEL FILTER AND PREFILTER CARTRIDGE REPLACEMENT
ENGINE VERSION
(1)
Par. 3.2.2
(1)
.
Fig. 5.1
Fig. 5.2
5
PERIOD (HOURS) -
6.3
250
500
see Par. 1.6
33
).
EN