Kohler KDI 3404TCR Owner's Manual page 47

INFORMATION ABOUT WARRANTY
6. MAINTENANCE AND REPAIR REQUIREMENTS
The owner is responsible for the proper use and maintenance of the engine. Kohler Co. recommends that all
receipts and records covering the performance of regular maintenance be retained in case questions arise. If the
engine is resold during the warranty period, the maintenance records should be transferred to each subsequent
owner. Kohler Co. may not deny warranty repairs solely because of the lack of repair, maintenance or failure to
keep maintenance records.
Normal maintenance, replacement or repair of emission control devices and systems may be performed by any
repair establishment or individual; however, warranty repairs must be performed by a Kohler authorized service
center.
7. CALIFORNIA AND FEDERAL EMISSION CONTROLWARRANTY STATEMENT, OFF-ROAD & MARINE
DIESEL ENGINES (USA ONLY)
The California air resources board (carb), U.S. environmental protection agency (EPA), and Kohler Co. are pleased
to explain the emission control system warranty on your [current model year – {2+ current model year}] off-road
compression ignition and marine (diesel) engine. In California ("the state") and US EPA regulated region, new
heavy-duty off-road & marine engines must be designed, built and equipped to meet the state's and US EPA anti-
smog standards. The warranty period shall begin on the date the engine or equipment is delivered to an ultimate
purchaser. Kohler Co. must warrant the emission control system on your engine for the periods of time listed in the
section below, provided there has been no abuse, neglect or improper maintenance of your engine.
Your emission control system may include parts such as the fuel injection system and the air-induction system.
Also included maybe hoses, belts, connectors and other emission related assemblies.
When a warrantable condition exists, Kohler Co. will repair your heavy-duty off-road & marine engine at no cost to
you including diagnosis, parts and labor.
The owner shall not be charged for diagnostic labor that leads to the determination that a warranted part is in fact
defective, provided that such diagnostic work is performed at a warranty station.
MANUFACTURER'S WARRANTY COVERAGE
The [current model year – {2+ current model year}] heavy-duty off-road & marine engines are warranted for the
periods listed below. If any emission-related part on your engine is defective, the part will be repaired or replaced
by Kohler Co.
VARIABLE SPEED OR
CONSTANT SPEED
Constant speed
Constant speed
Constant speed
Variable speed or constant
speed
KW <19 ANY SPEED
19 ≤kW 3,000 rpm or
<37 higher
19 ≤kW Less than 3,000
<37 rpm
19 ≤kW
Any speed
<37
kW ≥ 37 Any speed
1,500 HOURS OR TWO YEARS,
WHICHEVER COMES FIRST
1,500 hours or two years, whichever comes
first
3,000 hours or five years, whichever comes
first
3,000 hours or five years, whichever comes
first
3,000 hours or five years, whichever comes
firs
8
47
EN