Doosan D50S-5 Operation & Maintenance Manual page 167

3. 3. Install the drain plug. Install the drain plug.
ZF 3WG116 ZF 3WG116
Typical Example Typical Example
ZF ZF 3WG94 3WG94
Typical Example Typical Example
Typical Example Typical Example
8. 8. Remove Remove
compartment with oil. See "Refill Capacities". compartment with oil. See "Refill Capacities".
Install the dip stick/filter cap. Install the dip stick/filter cap.
D50/60/70/80/90S-5 D50/60/70/80/90 S-5 (3 (3 Speed)
D50/60/70/80/90 D50/60/70/80/90S-5 S-5 (3 (3 Speed)
D50/60/70 D50/60/70 S-5 S-5 (2 (2 Speed), Speed), G50/60/70S G50/60/70S -5 -5
the the dip dip stick/filter stick/filter cap. cap.
D50/60/70/80/90S-5 (3 Speed) D50/60/70/80/90S-5 (3 Speed)
: Every 1,000 Service Hours or 6 Months. : Every 1,000 Service Hours or 6 Months.
D50/60/70S-5 (2 Speed), G50/60/70S-5 D50/60/70S-5 (2 Speed), G50/60/70S-5
: Every 500 Service Hours or 3 Months. : Every 500 Service Hours or 3 Months.
5. 5. Put a small amount of clean oil on the seal Put a small amount of clean oil on the seal
gasket on the new filter. Install the filter by hand. gasket on the new filter. Install the filter by hand.
When the filter contacts the base, tighten it an When the filter contacts the base, tighten it an
additional 3/4 turn. additional 3/4 turn.
6. 6. Close the hood and seat assembly.
Close the hood and seat assembly.
7. 7. Open the access door in the floor plate. Open the access door in the floor plate.
Speed)
Typical Example Typical Example
Speed)
166 166
Drive Axle Oil - Change Drive Axle Oil - Change
Park the lift truck on a level surface, parking brake Park the lift truck on a level surface, parking brake
applied, transmission in neutral. applied, transmission in neutral.
Hot oil and components can cause personal Hot oil and components can cause personal
injury. Do not allow hot oil or components to injury. Do not allow hot oil or components to
contact skin. contact skin.
Shoe Brake Type Shoe Brake Type
Fill Fill the the
D50/60/70/80/90S-5 D50/60/70/8 0/90S-5 (3 (3 Speed) Speed)
Maintenance Section Maintenance Section
WARNING WARNING