Related Manuals for Gold Medal 2174EL/ER
Summary of Contents for Gold Medal 2174EL/ER
- Page 1 Part No. 46147 Revised April 2005 CORN TREAT , COMBO KANDY KING, AND PRALINATOR Instruction Manual Model #2174EL/ER & 2175EL/ER Model #2183EL/ER & 2182EL/ER Model #2180EL/ER & 2181EL/ER...
-
Page 2: Safety Precautions
SAFETY PRECAUTIONS... - Page 3 CORNTREAT, PRALINATOR, AND COMBO KANDY KING TABLE OF CONTENTS Section…………………………………………………….……...PG Corn Treat……………………………………………………………………..10 Pralinator………………………………………………………………………15 Combo Kandy King…………………………………………………………...19 MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
- Page 4 For Pralinators, the height from the base is 8” shorter or 23”. Agency Approvals: U.L., NSF Gold Medal Products Co. 10700 Medallion Drive Cincinnati, Ohio 45241-4807 Phone: 513-769-7676 fax: 513-769-8500 e-mail: www.gmpopcorn.com 11/02 MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
-
Page 5: Installation
Any claims should be filed immediately with the transportation company. ELECTRICAL REQUIREMENTS Voltage for the 2174EL/ER, 2180EL/ER, 2183EL/ER is 120 volt, 60 cycle single phase. A wall receptacle is not supplied. Only for the 2175EL/ER, 2181EL/ER, 2182EL/ER This receptacle will accept the attachment plug on your machine and must be used. -
Page 6: Controls And Their Function
The mixing drum can be taken to the sink to clean. The cabinet of your machine should be wiped cleaned daily; or more, depending on your usage. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER... - Page 7 7. After the hub seal assembly has been properly installed, place the new mix paddle on the bottom and one existing paddle on the top of the agitator shaft. 8. Replace the wing bolts and finger tighten. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
-
Page 8: Maintenance Instructions
CORNTREAT, PRALINATOR, AND COMBO KANDY KING MAINTENANCE INSTRUCTIONS MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER... -
Page 9: Ordering Spare Parts
4. Address all parts orders to: Parts Department Gold Medal Products Co. 10700 Medallion Drive Cincinnati, Ohio 45241-4807 or, place orders at: (800) 543-0862 (513) 769-7676 Fax: (513) 769-8500 E-mail: info@gmpopcorn.com Web Page: www.gmpopcorn.com MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER... - Page 10 2. Set the Pralinator/Corn Treat switch to the Corn Treat position (for Combo Kandy King only). 3. Turn the heat switch "ON". 4. Add 10-12 ounces of water, one carton of Gold Medal Caramel Corn Mix and four (4) cups of granulated sugar.
-
Page 11: Parts List
46326 46326 500 ohm Potentiometer 48688 48688 48688 48688 Percentage Timer 55057 55057 55057 55057 RTD Temperature Control 48689 48689 48689 48689 240k Resistor Red-Yel-Yel 48690 48690 48690 48690 750k Resistor Violet-Green-Yel MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER... - Page 12 CORNTREAT, PRALINATOR, AND COMBO KANDY KING Picture for parts list. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
-
Page 13: Electric Schematic
CORNTREAT, PRALINATOR, AND COMBO KANDY KING ELECTRIC SCHEMATIC This is for the 2174ER AND 2174EL. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER... - Page 14 CORNTREAT, PRALINATOR, AND COMBO KANDY KING ELECTRIC SCHEMATIC This is for the 2175EL and 2175ER. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
- Page 15 2. Set the Pralinator/Corn Treat switch to the Pralinator position (for Combo Kandy King only). 3. Make a solution of (3) parts water to (1) part Gold Medal imitation vanilla (item #4515). We recommend making at least one gallon of this “vanilla water” (1qt. of item #4515 + 3 qts. water).
- Page 16 500 ohm Potentiometer 48688 48688 48688 48688 48688 Percentage Timer 55057 55057 55057 55057 55057 RTD Temperature Control 48691 48691 48691 48691 48691 910k Resistor White-Brn-Yel 48692 48692 48692 48692 48692 82k Resistor Grey-Red-Org MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
- Page 17 CORNTREAT, PRALINATOR, AND COMBO KANDY KING ELECTRIC SCHEMATIC This is for the 2180ER AND 2180EL. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
- Page 18 CORNTREAT, PRALINATOR, AND COMBO KANDY KING ELECTRIC SCHEMATIC This is for the 2181ER AND 2181EL. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
- Page 19 D. Mount the large drum for the Corn Treat. Mount the small drum for the Pralinator. E. After the change over, follow the instructions on the mix package or turn to pages 11 for caramel corn and page 17 for frosted nuts for mixing instructions. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
- Page 20 48689 48689 48689 48689 48689 240k Resistor Red-Yel-Yel 48690 48690 48690 48690 48690 750k Resistor Violet-Green-Yel 48691 48691 48691 48691 48691 910k Resistor White-Brn-Yel 48692 48692 48692 48692 48692 82k Resistor Grey-Red-Org MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
- Page 21 CORNTREAT, PRALINATOR, AND COMBO KANDY KING ELECTRIC SCHEMATIC This is for the 2183ER, 2183EL, 2182ER AND 2182EL. MODEL # 2174EL/ER, 2175EL/ER, 2180ER/EL, 2181EL/ER, 2183EL/ER, 2182EL/ER...
-
Page 22: Warranty
CORNTREAT, PRALINATOR, AND COMBO KANDY KING WARRANTY WE WARRANT to the original purchaser the Gold Medal equipment sold by us to be free from defects in material or workmanship under normal use and service. Our obligation under this warranty shall be limited to the repair or replacement of any...