Table of Contents
Advertisement
Zoeller Pump Company warrants, to the purchaser and subsequent
owner during the warranty period, every new Zoeller Pump Company
product to be free from defects in material and workmanship under
normal use and service, when properly installed, used and maintained,
for a period of one year from date of installation or 18 months from
date of manufacturer, whichever comes first. Parts that fail, (within one
year of installation or 18 months from date of manufacturer, whichever
comes first) that inspections determine to be defective in material or
workmanship, will be repaired, replaced or remanufactured at Zoeller
Pump Company's option, provided however, that by so doing we will
not be obligated to replace an entire assembly, the entire mechanism
or the complete unit. No allowance will be made for shipping charges,
damages, labor or other charges that may occur due to product failure,
repair or replacement.
This warranty does not apply to any material that has been disassembled
without prior approval of Zoeller Pump Company, subjected to misuse,
misapplication, neglect, alteration, accident or act of God; that has not
been installed, operated or maintained in accordance with Zoeller Pump
Company installation instructions; that has been exposed to but not
limited to the following: sand, gravel, cement, mud, tar, hydrocarbons
or hydrocarbon derivatives (oil, gasoline, solvents, etc), wash towels
or feminine sanitary products, etc. or other abrasive or corrosive
ELECTRICAL PRECAUTIONS- Before servicing a pump, always shut off the main power breaker and then unplug the pump - mak-
ing sure you are not standing in water and wearing insulated protective sole shoes. Under flooded conditions, contact your local electric company or a
qualified licensed electrician for disconnecting electrical service prior to pump removal.
Submersible pumps can become pressurized under normal operating conditions — allow 2½ hours after disconnecting before attempting service.
CONDITION
A.
Pump will not start or run.
B. Motor overheats and trips overload
or blows fuse.
C. Pump starts and stops too often.
D. Pump will not shut off.
E. Pump operates but delivers little
or no water.
F.
Drop in head and/or capacity after
a period of use.
G. If tank or fittings leak.
If the above checklist does not uncover the problem, consult the factory - Do not attempt to service or otherwise disassemble pump. Service must
be by Zoeller Authorized Service Stations.
Limited Warranty
Service Checklist
COMMON CAUSES
Check fuse, low voltage, overload open, open or incorrect wiring, open switch, impeller or seal bound mechani-
cally, defective capacitor or relay when used, motor or wiring shorted. Float assembly held down. Switch defective,
damaged, or out of adjustment.
Incorrect voltage, negative head (discharge open lower than normal) impeller or seal bound mechanically, defec-
tive capacitor or relay, motor shorted.
Float switch stops mislocated (model 135 only), float too tight on rod, check valve stuck, or none installed in long
distance line, overload open, switch defective.
Debris under float assembly, float or float rod bound by basin sides or other, switch defective, damaged or out of adjustment.
Check strainer housing, discharge pipe, or if check valve is used, the vent hole must be clear. Discharge head
exceeds pump capacity. Low or incorrect voltage. Incorrect motor rotation. Capacitor defective. Incoming water
containing air or causing air to enter pumping chamber.
Increased pipe friction, clogged line or check valve. Abrasive material and adverse chemicals could possibly
deteriorate impeller and pump housing. Check line. Remove base and inspect.
Carefully tighten pipe joints (use pipe dope) and screws. Check gasket location, tighten lid evenly. Do not over
tighten fittings or screws.
© Copyright 2012 Zoeller Co. All rights reserved.
substances. This warranty is in lieu of all other warranties expressed
or implied; and we do not authorize any representative or other person
to assume for us any other liability in connection with our products.
Contact Zoeller Pump Company, 3649 Cane Run Road, Louisville,
Kentucky 40211-1961, Attention: Customer Service Department
to obtain any needed repair or replacement of part(s) or additional
information pertaining to our warranty.
ZOELLER PUMP COMPANY EXPRESSLY DISCLAIMS LIABILITY
FOR SPECIAL, CONSEQUENTIAL OR INCIDENTAL DAMAGES
OR BREACH OF EXPRESSED OR IMPLIED WARRANTY; AND
ANY IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR
PURPOSE AND OF MERCHANTABILITY SHALL BE LIMITED TO
THE DURATION OF THE EXPRESSED WARRANTY.
Some states do not allow limitations on the duration of an implied
warranty, so the above limitation may not apply to you. Some states
do not allow the exclusion or limitation of incidental or consequential
damages, so the above limitation or exclusion may not apply to you.
This warranty gives you specific legal rights and you may also have
other rights which vary from state to state.
2
Advertisement
Table of Contents
