Cleveland SteamChef 22CGT3.1 Operation Installation Maintenance Manual page 45

Control panel POWER
indicator light ON and
SteamChef does not
make steam in MANUAL
or TIMED Modes.
Control panel Power
indicator is on, buzzer is
buzzing continuously,
and Reset indicator is lit.
Control panel Power
indicator is on, buzzer is
buzzing continuously.
Compartment bottom
dirty with food drippings.
Abnormal amount of
steam coming from drain
during draining of
SteamChef
Steam and/or water
draining around the
compartment door.
See Warning under
Note 7.
PROBLEM
Steam and/or water
draining around the
compartment door.
High limit switch has tripped.
Inoperative controls.
Water supply to SteamChef shut OFF.
Door interlock switch not engaged or
has failed.
Water line strainer and/or external filter
is clogged.
Gas supply valve is closed.
Inoperative controls or solenoid.
High limit has tripped.
Inoperative controls.
Burner has failed to light.
Juices and/or food leaking from pans
during loading and unloading of the
SteamChef.
KleanShield not installed.
ON/OFF lever not all the way OFF.
Water line strainer and/or external filter
system clogged.
3-minute drain rinse timer defective.
Hot water instead of cold water
connected to reservoir fill line.
Inoperative controls.
The KleanShield™ drain or the main
drain is clogged or covered.
Door gasket or door parts worn.
Hot water instead of cold water
connected to the condenser water line.
Troubleshooting Guide(Continued)
POSSIBLE CAUSE
External drain not properly sized,
installed, free air vented, and/or
pitched down.
SteamChef not level.
Reset the SteamChef according to
instructions found in Chapter 3 If the
condition repeats, see Note 1.
See Note 1.
Open water supply valves.
Close door completely. If problem
persists, see Note 1.
Clean water supply strainer and/or
external filter system.
Open gas supply valve.
Reset the SteamChef according to
instructions found in Chapter 3 If the
condition repeats, see Note 1.
See Note 1.
See Note 1.
Reset the SteamChef according to
instructions found in Chapter 3,
"Lighting Instructions". See Note 1.
Put a solid pan under perforated pans
to catch drippings.
Put less food in pan.
Install KleanShield to catch food
drippings.
Turn ON/OFF lever all the way OFF to
start the 3-minute drain rinse cycle.
Clean water supply strainer and/or
filter system.
Call for service. See Note 1.
See Note 2 and 3.
Call for service. See Note 1.
Clear the drain opening and/or clean
the drain with NSF approved drain
cleaner and flush drain thoroughly with
fresh water.
If condition persists, see Note 1.
Call for service. See Note 1.
See Notes 1, 2 and 3.
REMEDY/REFERENCE
Verify drain sized and installed
properly. See the Installation Manual
See Notes 2 and 3.
See Note 2.
39