Montigo PL60VO Installation & Maintenance Manual page 7

Appliance Certification
Certification
Standard: ANSI Z21.97-2014/CSA 2.41-2014
Type of Appliance: Outdoor Decorative Gas Appliance
Approvals: Approved for use in USA and Canada. Approved for use in the
State of Massachusetts
Certification Agency: Canadian Standards Association (CSA)
Installation Standards:
The installations must confirm with the requirements listed in this
document and to local codes. In the absence of local codes, it must
conform to the National Standards listed below. The appliance must be
electrically wired and grounded in accordance with the local codes and in
the absence of local codes must confirm to the National Standards listed
below.
USA: National Fuel Gas Code: ANSI 223.1/NFPA54
National Electrical Code: NFPA 70
Canada: Natural Gas and Propane Installation Code CSAB149.1
Canadian Electrical Code CSA 22.1
ORIFICE
MODEL FUEL
SIZE
PL42VONE Natural Gas 1.45mmx3
PL42VOLE Propane Gas #64x3
PL60VONE Natural Gas 1.45mmx5
PL60VOLE Propane Gas #64x5
Figure 5
PL42VO, PL60VO Gas Standards
High Altitude Installations:
If the heating value of the Natural Gas or Propane supply is derated to
compensate for the high altitude, the following requirements may not apply.
Please check with your local gas supplier or authority having jurisdiction
and contact your Montigo dealer.
USA: This appliance is approved for installations up to an altitude of 2000 ft.
(610 m) above sea level. For installations beyond this level, please contact
your Montigo dealer for high altitude conversion kits.
CANADA: This appliance is approved for installations up to an altitude of
4500 ft. (1370m) above sea level. For installations beyond this level, please
contact your Montigo dealer for high altitude conversion kits.
XG0219 - 170829
MAX. INPUT MIN GAS INLET
Btu/Hr PRESSURES
28,000 5.5" W.C.
28,000 11.0" W.C.
47,000 5.5" W.C.
47,000 11.0" W.C.
General Information & Safety
Operational Warnings
WARNING!
Initial Lighting: When lit for the first time, the appliance
emits a slight odor. This is a normal temporary condition caused
by the "burn-off" of internal paints and lubricants used in the
manufacturing process and does not occur again. Simply run the main
burner on high for up to 8 hours.
WARNING!
You must have clear and easy access to the manual
shut off valve AFTER the appliance is installed and connected to
the gas supply in order to safely turn off the gas to the appliance for
emergencies.
WARNING!
Never use this appliance for other than the intended use.
WARNING!
• Children and adults should be alerted to the hazards of high surface
temperatures and should stay away from the appliance to avoid
burns or clothing ignition.
• Children should be carefully supervised when they are in the area of
the appliance.
• Maintain 36" clearance from appliance front to any combustible
material.
• Clothing or other flammable materials should not be hung from the
appliance, or placed on or near the appliance.
• Any guard or protective device removed for servicing the appliance
must be replaced prior to operating the appliance.
• Installation and repair should be done by a qualified service person.
• The appliance should be inspected before each use and at least
annually by a qualified service person. More frequent cleaning
may be required as necessary. It is imperative that the control
compartment, burners and circulating air passageways of the
appliance be kept clean.
NOTE
The appliance has been designed with several safety features,
which include a safety valve. If the burner flame is extinguished the
appliance will automatically shut down.
This appliance is also equipped with two air proving switches
which will shut off gas to the burner if the air supply to the unit is
compromised.
WARNING!
Any modification to the appliance may compromise the
safety of this appliance.
Do not operate the appliance if any part has been under water.
Immediately call a qualified service technician to inspect the appliance
and replace any part of the control system and any gas control, which
has been underwater.
Page 7