Safety Instructions For Maintenance And Servicing; General; Protective Devices - HAKO Citymaster 2200 Operating Manual

1.5

Safety instructions for maintenance and servicing

1.5.1

General

Danger
It is not permitted to stand underneath the dirt hopper if it is not secured. Always fit the safety strut
•
whenever working underneath the dirt hopper. There is a danger to life!
Special caution is required in the area of the front and rear-mounted equipment and attachments.
•
There is a danger to life!
Perform maintenance and repair work under a jacked up vehicle or attachment only if it is safely
•
and securely supported (hydraulic cylinders, jacks, etc. alone do not secure a jacked-up vehicle).
There is a risk of injury!
• Do not perform any welding, drilling, sawing or grinding work on parts of the frame. Damaged
parts may be replaced only by your authorised Hako dealer. There is a risk of accidents!
Adopt measures against erroneous starting and unwanted movement. Operate the parking brake.
•
Switch the engine off and pull out the ignition key. There is a risk of accidents!
If dismantling safety devices is required in equipping, maintenance and repair work, fit and check
•
the safety devices immediately after completion of the work. There is a risk of accidents!
Attention
• Daily and weekly maintenance work must be done by the operating staff. In all other maintenance
work, please contact your nearest authorised Hako dealer.
Apart from the regular general inspection, the vehicle and the attachments must be maintained at
•
regular intervals according to BGV, D 29 and be checked at least annually for operationally safe
condition.
Spare parts must be original spare parts to guarantee safety.
•
Use suitable tools for the cleaning and maintenance work.
•
• Do not use steam cleaners and high-pressure cleaners (option) for cleaning electrical/electronic
components and the engine compartment!
After cleaning, examine all fuel, engine oil and hydraulic pipes for leaks, abrasion places and
•
damage. Immediately rectify any damage found!
Always tighten screw connections loosened in maintenance and repair work.
•
1.5.2

Protective devices

Danger
It is not permitted to stand underneath the dirt hopper if it is not secured. Always fit the safety strut
•
whenever working underneath the dirt hopper. There is a danger to life!
• Special caution is required in the area of the front and rear-mounted equipment and attachments.
There is a danger to life!
Put the vehicle into service only if all protective devices are attached and in protection position.
•
There is a risk of injury!
Do not touch any parts such as engine block, cooling system and exhaust system during
•
operation and for some time after. There is a risk of burns!
01-1481-00-00.fm
Safety instructions
17