Mechanical Specifications; Electrical Specifications - Maximum Controls MAX Ultra Arm Manual

max ultra arm
Max Gate
Weight/Length
MECHANICAL SPECIFICA TIONS
8ft 12ft 16ft
5"
127mm
7.35"
186mm
5.07"
128mm
2
• Shipping weight of Actuator: Max Ultra Arm (27 lbs)
• Shipping weight of AC Control Box (38 lbs)
• Stainless steel output shaft 2" tubular
• Direct gear drive (no internal chains, belts, or pulleys)
• Mechanical and electrical gate release functions
• Corrosion protection: powder coated alumminum housing
• Continue cycles at extreme temperature ranges. No overheating
• Limit Switch base Intelligent ramp-up and ramp-down for smooth gate operation
ELECTRICAL SPECIFICA TIONS
• 24 Volt DC motor
• Two independently adjustable closing speed controls with 16 positions each
• Switchable 115/230 voltage selection
• Adaptive DSP motor control for advanced motion control
• Real time performance analyzer and event log (OBD PORT and Black Box)
• Magic Box enables low voltage wiring capabilities for remote power up to 1000 ft
• On-board switch for solar mode enables 5 milliamp idle in sleep mode
• Gold contact input connections and automobile grade connectors
• -4F? to 165F? (-20C to +74C) operational range including battery backup without a heater
= Unique to Max Ultra Arm
Max gate weight per leaf .....1200 lbs (550 kg)
Max gate length per leaf .....157.4 in (4 m)
MAX UL TRA ARM
Power supply .....24 VDC
Max Stroke length .....21.2 in (540 mm)
Nominal thrust .....5500 N
Maximum operating current .....6A for max 10 sec
Operating Temperatures .....-20°C ~+50°C
J3
18ft
Min = 39.1" (993.5 mm)
max ultra arm
Max = 60.3" (+/-.39") (1531 mm (+/- 10 mm)
5"
127mm
7.35"
186mm
5.07"
128mm
2
UL 325 Type B1 (photo cell) and Type B2 (sensing edge)
MOTOR 1 +
ERROR E 1/2 F INPUTS [-]
BATTERY
BATTERY
INPUT
BACKUP MODE
MONITORED when used. [+]
BATTERY MOTOR 2
LEAVE OPEN
IN USE INPUTS [-]
OPEN 1 TIME
REPLACE LIMIT 1
LEAVE
BATTERY MOTOR 1
BATTERY CLOSED
LIMIT 2
POWER / TEST
SOLAR IN LIMIT 1
POWER MOTOR 2
CLOSE LIMIT 2
ERD SENSITIVITY
TIMER
14 12 14 12
16 16
MIN MIN
ERD ERD
9 9
1 1
MODULE MAX MOTOR MAX MOTOR
SENSE OVER SENSE OVER LIMIT 1
PORT 3 7 3 7
LOAD LOAD MIN MAX MOTOR 1
GND
OPENING CLOSING OFF
LIMITS
LIMIT 2
OBD PORT
BLACK BOX
LIMIT 1
MAXIMUM CONTROLS
RESET
OFF MOTOR 2
GND
DSP ARM CONTROLLER LIMITS
1 LIMIT 2
ON/OFF
2
ALARM BATTERY
3
4
5 PROGRAMMING MOTION CONTROL JOG GATE OPEN
ID PLUG
6
ERROR
COM
1
GATE CLOSED
2
ID 3
4
PLUG 5 GND
6
OPEN CLOSE
7 PROGRAM OPEN STOP CLOSE MAG NO
8
9 LOCK COM
10
OFF
NC
ANTI- PUSH PULL MAGLOCK
EXIT PWR
SOLAR MODE TAILGATE
OPEN OPEN DELAY
EXIT LOOP OPEN ONLY NC
OFF ON
GND
PHOTO CLS NC
OFF ON
GATE
CENTER LOOP
OFF 2.5 sec OPEN / CLS NC
LOOP PWR CLOSING GATE SPEED
1.5 sec
12VDC OUT
OPERATOR
SAFETY LOOP MIN MIN
GND
FAULTS
MAX MAX UL OPEN ONLY 10K
SINGLE DUAL
24VDC OUTPUT
ENTRAP CLS ONLY 10K
MOTOR 1 MOTOR 2
GND
OPEN / CLS 10K
12VDC OUTPUT
12VDC OUT
GND
GND
AVERTISSEMENT: pour ne pas compromettre la
protection contre les risques d'incendie, utiliser un
fusible de mêmes type et caractéristiques nominales.
WARNING: For continued protection
7A
against fire, replace only with the
FUSE
same type and rating of fuse.
EXIT CENTER SAFETY
On Select Input Voltage
J4 J5
115VAC or 230VAC
Off
POWER
115VAC
POWER IN
3A max
Max Gate
Weight/Length
8ft 12ft 16ft
EXIT CENTER SAFETY
J3 J4 J5
FEATURE LIST:
17"
max ultra arm
(AC)
Max gate weight per leaf .....1200 lbs (550 kg)
Max gate length per leaf .....157.4 in (4 m)
8ft 12ft
Power supply .....24 VDC
Max Stroke length .....21.2 in (540 mm)
Nominal thrust .....5500 N
Maximum operating current .....6A for max 10 sec
Operating Temperatures .....-20°C ~+50°C
MAX Ultra Arm V1
18ft
5"
127mm
7.35"
186mm
Min = 39.1" (993.5 mm)
5.07"
128mm
Max = 60.3" (+/-.39") (1531 mm (+/- 10 mm)
2
WARNING: For continued protection
7A
against fire, replace only with the Input AC power/amps.....
FUSE
same type and rating of fuse.
On Select Input Voltage
115VAC or 230VAC
Switchable: 115VAC / 6 amp
Off
POWER
115VAC
POWER IN
3A max
(AC)
RESET ALARM
230VAC / 2 amp
Power output.....24 VDC
JOG GATE
OPEN / CLOSE
Operating temperature .....-
Cycles per hour AC input po
Battery back-up cycles.....
(7 Amp/Hr batteries fully ch
Entrapment protection .....
Gate Capacity
- UL 325 Type A Inherent
- Inputs for NORMALLY C
UL 325 Type B1 (photo
Max Gate
MONITORED when used
Weight/Length
16ft 18ft
Min = 39.1
Max = 60.3" (+/-.39"
OR
Max
Max
Powe
Max
Nom
Maxi
Oper