Operation; Controls; Main Power Switch Light; Ready Light - Vulcan-Hart C24EA Series Installation & Operation Manual

C24EA SERIES ELECTRIC COUNTER CONVECTION STEAMERS

CONTROLS

Controls for SonicSafe are
shown in Figure 3.
Sonic
Safe
Call
Service
SonicSafe
Figure 3

Main Power Switch Light

ON The steam generator will automatically
fi ll and begin heating to the preset
temperature.
OFF The steam generator will drain, switch
power light will turn off .

Ready Light

The ready light indicates that the steamer is
ready for the cooking cycle.

Cooking Light

The cooking light indicates that the steamer is
in the cooking cycle.

Timer

Set the cooking time (0 to 60 minutes). Steam
cooking will begin when the door is closed. The
cooking cycle will be interrupted if the door is
open during the cooking cycle; resume cooking
by closing the door.

OPERATION

When done, a buzzer sounds and steam stops
being supplied to the cooking chamber. Turn
the timer OFF to stop the buzzer.
are hot. Use care when operating, cleaning
or servicing the steamer. The cooking
compartment contains live steam. Stay
clear while opening the door.
Once the steamer is installed and all mechanical
connections have been made, thoroughly test
the steamer before operation.
1. Check that proper water, drain, and electrical
connections have been made.
2. Open water valve.
3. Press the power switch to the ON position.
Wait approximately 8-10 minutes.
4. Open the door and observe that no steam
is entering the compartment, and that the
ready light is ON and the cooking light is
OFF.
5. Set the timer to the 5 minute position.
Close the compartment door. The cooking
light should now be lit and steam should
be heard entering the compartment. Wait
approximately 2-3 minutes.
6. Check drain line to ensure that water from
the cold-water condensate valve is fl owing
through the drain line.
7. Open the compartment door and observe
that steam supply to the compartment stops
and that the cooking light is OFF.
8. Close compartment door and let cooking
cycle fi nish. When timer returns to 0, the
buzzer will sound, signaling the end of the
cooking cycle. To silence the buzzer, turn
the timer dial to OFF.
9. To shut down the steamer, turn off the power
switch. Leave the compartment doors slightly
open to allow the inside to dry out.
— 10 —

START UP

The steamer and its parts