Transportation And Handling; Factory-Supplied Accessories - Hitachi RAS-5FSN Installation And Operation Manual

10. TRANSPORTATION AND HANDLING

10.1. TRANSPORTATION OF OUTDOOR UNIT
1. Hanging Method
When hanging the unit, ensure a balance of the unit, check
safety and lift up smoothly.
For Transportation
-
Do not remove any packing materials.
-
Hang the unit under packing condition with ropes
through the each square hole an apply the splints or
corrugated paper for the unit protection.
DANGER:
Do not hang ropes at the wooden base.
Rope
Wooden Base
For Installation RAS-5~16FSN ; RAS-8~10FXN(E)
-
Remove the wooden base.
-
Apply two (2) ropes on the splints or corrugated paper
to protect the unit, and hang the unit as shown below.
Do not remove
paper frame and
plastic band
Apply rope on
the splints or
corrugated
paper more
than 15mm
thickness.
Apply rope through the square hole

10.2. FACTORY-SUPPLIED ACCESSORIES:

5FSN
Accessory Q'ty
Compressed Sheet - -
Pipe Flange of
Refrigerant Gas - -
Piping
Pipe with Flare Nut
of Refrigerant Gas - 1
Piping
Pipe with Flare Nut
of Refrigerant - -
Liquid Piping
4
Rubber Bush
1
Screw 3
NOTE:
If any of these accessories are not packed with the unit, please contact your contractor.
Rope
Angle of Wire
more than 60º
Do not apply any
force to this plate.
(Both Side)
8FSN(E) 10FSN(E) 16FSN 20FSN
- 1 1 1
- 1 1 1
1 - - -
- - - -
For Connection Hole of Operation Wiring
For Connection Hole of Power Source Wiring
TRANSPORTATION AND HANDLING
(
Rope Position)
Rope
Square Square
Hole Hole
CORRECT INCORRECT
For Installation RAS-20~30FSN ; RAS-16~30FXN
Hang the unit under packing condition with four (4)
ropes.
Push through the wire ropes into the hang hole and
clamp the wires by using shackle as shown below.
2. Before Installation
Before installation work, check the availability of the
following parts which are packed inside the outdoor unit
fixed to the base plate.
24FSN 30FSN 8FXN(E) 10FXN(E) 16FXN
1 1 1 1
1 1 1 1
- - 1 1
1 1 - -
Spare
11
Rope
Wire Rope
Do not remove
wooden frame and
plastic band
Angle of Wire more
than 60°
Do not apply any
force to this plate
(Both Sides)
Push through wire
rope into the hang
clamp it by using
shackle
20FXN 24FXN 30FXN
2 2 2 2
2 2 2 2
- - - -
- - 1 1