Toro Reelmaster 335-D Service Manual page 192

Starting Problems (continued)
Condition
__________________________________________________________________________________________
Nothing happens when start at-
tempt is made.
Troubleshooting
Possible Cause
Battery is dead.
Loose or corroded battery cables.
Loose or corroded ground.
"Run" fuse open.
Fusible link open.
Temp. switch or relay faulty.
Temp relay wiring loose, corroded
or damaged.
Traction switch out of adjustment
or faulty.
Traction switch wiring loose, cor­
roded or damaged.
PTO switch engaged or faulty.
PTO switch wiring loose, corroded
or damaged.
Ignition switch faulty.
Ignition switch wiring loose, cor­
roded or damaged.
Start relay faulty.
Start relay wires loose, corroded or
damaged.
In-line 30 amp starter solenoid fuse
open.
Starter solenoid wiring loose, cor­
roded or damaged.
Starter solenoid faulty.
Page 5 - 8
Correction
Charge battery. Replace battery if
it will not hold a charge.
Clean and tighten or repair as
necessary.
Check fuse and replace if fuse is
open. If fuse burns out often, find
and correct cause.
Replace fusible link.
Test temp. switch and relay. Re­
place if faulty.
Repair wiring.
Test traction switch. Adjust or re­
place traction switch if faulty.
Repair wiring.
Make sure PTO switch is OFF.
Test switch and replace if faulty.
Repair wiring.
Test ignition switch. Replace if
faulty.
Repair wiring.
Test start relay. Replace if faulty.
Clean and tighten or repair as
necessary.
Check fuse and replace if fuse is
open. If fuse burns out often, find
and correct cause.
Clean and tighten or repair as
necessary.
Replace starter.
Reelmaster
®
335-D