Adding Front Brake Fluid; Changing The Front Brake Fluid - KTM 450 SX-F EU Repair Manual

13/BRAKE SYSTEM
100
Addinll front brake lIuid
Warninll
Danler of accidents
Failure of the brake system.
- If the brake fluid level fails below the
MIN
mark, this indicates a leakage in the brake system or worn-out brake linings.
Check the brake system and do not continue riding.
Warning
Skin irritation
Brake fluid can cause skin irritation on contact.
- Avoid contact with skin and eyes, and keep out of the reach of children.
- Wear suitable protective clothing and goggles.
- If brake fluid comes into contact with the eyes, flush the eyes thoroughly with water and consult a physician immediately.
Warning
Danler of accidents
Reduced braking efficiency due to old brake fluid.
- Change the brake fluid of the front and rear brake according to the service schedule.
Warning
Environmental hazard
Hazardous substances cause environmental damage.
- Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.
• Info
I
Never use DOT 5 brake fluid! It is silicone-based and purple in color. Oil seals and brake lines are not designed for DOT 5
brake fluid.
Avoid contact between brake fluid and painted parts. Brake fluid attacks paint!
Use only clean brake fluid from a sealed container.
- Move the brake fluid reservoir mounted on the handlebar to a horizontal position.
- Remove screws
- Remove cover with membrane
- Add brake fluid to level
Guideline
Dimension (brake fluid level below
5
mm (0.2 in)
top edge of container)
I
Brake fluid DOT
41
DOT 5.1 (r p. 224)
- Position the cover with the membrane. Mount and tighten the screws.
• Inlo
I
Clean up overflowed or spilt brake fluid immediately with water.
Cbanlli!.lll the front brake lIuid
Warning
Skin irritation
Brake fluid can cause skin irritation on contact.
- Avoid contact with skin and eyes, and keep out of the reach of children.
- Wear suitable protective clothing and goggles.
- If brake fluid comes into contact with the eyes, flush the eyes thoroughly with water and consult a physician immediately.
Warning
Environmental hazard Hazardous substances cause environmental damage.
- Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.