Perkins 1106D Troubleshooting Manual page 213

SENR9982
CID 0526 FMI 06 Turbo Wastegate Drive current
high ...................................................................... 98
CID 0526 FMI 07 Turbo Wastegate Drive not
responding properly ............................................. 98
CID 0774 FMI 02 Secondary Throttle Position Sensor
data erratic........................................................... 99
CID 0774 FMI 03 Sec Throttle Position Sensor
open/short to +batt............................................... 99
CID 0774 FMI 04 Sec Throttle Position Sensor short
to ground............................................................ 100
CID 0774 FMI 08 Sec Throttle Position Sensor signal
abnormal............................................................ 100
CID 1639 FMI 09 Machine Security System Module
not communicating on link ................................. 101
CID 1743 FMI 02 Engine Mode Selection Switch
State Incorrect ................................................... 101
CID 1779 FMI 05 Fuel Rail Pressure Valve 1 Solenoid
open circuit ........................................................ 102
CID 1779 FMI 06 Fuel Rail Pressure Valve 1 Solenoid
short to ground................................................... 102
CID 1785 FMI 03 Intake Manifold Pressure Sensor
voltage high ....................................................... 102
CID 1785 FMI 04 Intake Manifold Pressure Sensor
voltage low......................................................... 103
CID 1785 FMI 10 Intake Manifold Pressure Signal
abnormal rate of change.................................... 103
CID 1797 FMI 03 Fuel Rail Pressure Sensor
open/short to +batt............................................. 104
CID 1797 FMI 04 Fuel Rail Pressure Sensor short to
ground................................................................ 104
CID 1834 FMI 02 Ignition Key Switch loss of
signal ................................................................. 105
CID 2246 FMI 06 Glow Plug Start Aid Relay Current
High ................................................................... 105
Coolant in Engine Oil............................................. 46
Probable Causes ............................................... 46
Recommended Actions...................................... 47
Coolant Temperature Is Too High .......................... 47
Probable Causes ............................................... 47
Recommended Actions...................................... 47
Customer Specified Parameters............................ 37
Configurable Inputs............................................ 38
ECM Identification Parameter ............................ 37
Engine Rating Parameter................................... 37
J1939 Continuous Fault Handling...................... 38
Low/High Idle Parameters.................................. 37
Miscellaneous .................................................... 38
PTO and Throttle Lock Parameters ................... 37
Customer Specified Parameters Table .................. 40
Customer Specified Parameters Worksheet ......... 41
D
Data Link Circuit - Test ........................................ 127
Diagnostic Code Cross Reference ........................ 74
Diagnostic Functional Tests.................................. 112
Digital Throttle Position Sensor Circuit - Test ...... 133
E
E172 High Air Filter Restriction ........................... 106
E2143 Low Engine Coolant Level ........................ 111
E232 High Fuel/Water Separator Water Level .... 106
E360 Low Engine Oil Pressure............................ 107
E361 High Engine Coolant Temperature ............. 108
E362 Engine Overspeed ..................................... 109
E396 High Fuel Rail Pressure ............................. 109
E398 Low Fuel Rail Pressure ............................... 110
E539 High Intake Manifold Air Temperature......... 110
ECM Harness Connector Terminals ...................... 26
Removal and Installation of the Harness Connector
Terminals.......................................................... 26
ECM Memory - Test............................................. 140
ECM Snapshot ...................................................... 28
Snapshot That is Triggered by a Diagnostic
Code................................................................. 29
Snapshot That is Triggered by the Operator...... 29
Use of Snapshot Data........................................ 29
ECM Will Not Accept Factory Passwords.............. 48
Probable Causes ............................................... 48
Recommended Actions...................................... 48
ECM Will Not Communicate with Other Systems or
Display Modules .................................................. 49
Probable Causes ............................................... 49
Recommended Actions...................................... 49
Electrical Connectors - Inspect............................ 141
Electronic Service Tool Will Not Communicate with
ECM..................................................................... 49
Probable Causes ............................................... 49
Recommended Actions...................................... 49
Electronic Service Tools ......................................... 11
Optional Service Tools ....................................... 12
Perkins Electronic Service Tool.......................... 12
Required Service Tools ...................................... 12
Electronic Troubleshooting ...................................... 5
Engine Cranks but Will Not Start ........................... 50
Probable Causes ............................................... 50
Recommended Actions...................................... 50
Engine Has Early Wear ......................................... 52
Probable Causes ............................................... 52
Recommended Actions...................................... 52
Engine Misfires, Runs Rough or Is Unstable......... 53
Probable Causes ............................................... 53
Recommended Actions...................................... 53
Engine Oil in Cooling System ................................ 55
Probable Causes ............................................... 55
Recommended Actions...................................... 55
Engine Pressure Sensor Open or Short Circuit -
Test .................................................................... 145
Engine Speed Does Not Change .......................... 55
Probable Causes ............................................... 55
Recommended Repairs ..................................... 55
Engine Speed/Timing Sensor Circuit - Test......... 152
Engine Stalls at Low RPM ..................................... 56
Probable Causes ............................................... 56
Recommended Actions...................................... 56
Engine Temperature Sensor Open or Short Circuit -
Test .................................................................... 158
Engine Vibration .................................................... 57
Probable Causes ............................................... 57
Recommended Actions...................................... 57
Engine Will Not Crank ........................................... 58
Probable Causes ............................................... 58
Recommended Repairs ..................................... 58
213
Index Section